Table des Matières
Publicité
Note: For fitting the Powered Air Turbo to the optional backpack, see Fig 7. Check that it is
firmly held in place by the attached fastening. If necessary, adjust backpack straps for a
comfortable fit.
Note: To fit the optional braces (Fig 8), slide the removable buckle portion and bar sliders
off the belt.
Slide two strap hangers (Fig 9) onto the belt so that they are in the position shown in Fig
10.
Slide one bar slider onto the belt (Fig 11), slide the belt through the Powered Air Turbo
(Fig 12) and slide another bar slider onto the belt.
Position the Powered Air Turbo and bar sliders as shown in Fig 13. Slide the other two
strap hangers and the last bar slider onto the belt (Fig 14). Reattach the buckle portion
(Fig 15).
Fit the belt around the waist and position hangers and sliders as shown in Fig 16. Clip the
front portion of the braces as shown in Fig 16. Attach the rear braces as shown in Fig 17.
Adjust the braces for a comfortable fit.
IN USE
Operation
Display
Sounder
Switching on
D
On (Normal Operation)
Switching off
Key
= Flash (3 times)
= One long beep
B
D
Use in the 'power-off' state is not normal, little or no protection is provided and a
build up of carbon dioxide and depletion of oxygen within the Headtop may occur,
vacate the contaminated area immediately.
Take care to prevent the breathing tube from becoming looped around protruding objects.
If during use, the airflow into the Headtop stops and the alarm sounds, vacate the
contaminated area immediately and investigate the cause (please see fault finding).
The 'in-use' life of the product will vary with frequency and conditions of use.
In everyday use, it is recommended that the product is discarded after approximately 5
years service, provided the product is stored and maintained as stated below.
Some extreme conditions may result in deterioration over a shorter period.
Note: Do not expose battery pack to temperatures above 54°C. The Powered Air Turbo
battery alarm will activate if battery pack temperature reaches 60°C while the Powered Air
Turbo is in use.
Do not use the batteries outside of the recommended temperature limits.
DOFFING
Do not remove the headtop or turn off the air supply until you have vacated the
contaminated area.
1. Lift the Headtop off the head.
2. Switch off the Powered Air Turbo by pressing the power button for 2 seconds.
3. Unbuckle the waist belt.
For long-term storage of filters, remove the filter and seal in a closed container. 3M does
not recommend the filter be left in place in the Powered Air Turbo as damage may occur
to the filter gasket.
NOTE If the respirator has been used in an area that has caused it to become
contaminated with a substance requiring special decontamination procedures it
should be placed in a suitable container and sealed until it can be decontaminated
or discarded.
CLEANING INSTRUCTIONS
Use a clean cloth dampened with a mild solution of water and liquid household soap.
Do not use petrol, chlorinated degreasing fluids (such as trichloroethylene), organic
solvents or abrasive cleaning agents to clean any part of the equipment.
To disinfect use wipes as detailed in Reference Leaflet.
^ Keep filter seal clean
^ Never attempt to clean filters by knocking or blowing out accumulated material.
Do not immerse the battery pack or battery charger into any type of liquid.
Do not wipe the electrical contacts.
MAINTENANCE
Maintenance, servicing and repair must only be carried out by properly trained personnel.
^ Use of unapproved parts or unauthorised modification could result in danger to
life or health and can invalidate any warranty.
If disposal of parts is required this should be undertaken in accordance with local health
and safety and environmental regulations.
^ Dispose of lithium ion battery packs according to local environmental regulations.
Do not dispose of in standard waste bins, in a fire or send for incineration.
Remove the battery by pressing on the battery latch and pulling the battery down and out.
Select an approved charger kit and refer to the user instructions provided with the kit.
^ Do not charge batteries with unapproved chargers, in enclosed cabinets without
ventilation, in hazardous locations or near sources of high heat.
^ Do not charge the batteries outside the recommended temperature range of 0-40°C.
The battery may be left on the charger. However, for long term storage of the batteries,
3M recommends that they are stored off the charger at approximately 40% charge. The
battery should never be left in a discharged state.
The standard economy battery lifetime is at least 1000 hours.
The high capacity battery lifetime is at least 2000 hours.
The battery is expected to maintain at least 80% of initial capacity for lifetime stated
above.
WHAT
WHEN
Airflow Check
Before use
General Inspection
Before use - Monthly if not in regular use
Cleaning
After use
FAULT FINDING
Warnings
Display Sounder
Comments
1. Charge battery
Low Battery
E
2. Battery pack has exceeded
operating temperature of 55°C
Low Flow
Hose blocked - Clear / Replace hose
E
Filters blocked - Replace filters
(Fig 3 and 4)
Low Flow and Battery
E
See above
Odour Detected
Replace filter Note: Applicable to
nuisance odour filters only
Key
B
= Slow Flash
E
= Short Intermittent Beep
NOTE: POWERED AIR TURBO WILL SHUT DOWN APPROXIMATELY 15 MINUTES
BEYOND LOW BATTERY WARNING OR IF INTERNAL BATTERY TEMPERATURE
EXCEEDS 60°C.
STORAGE AND TRANSPORTATION
^ Ensure filters and batteries are stored in accordance with instructions below.
This product should be stored in the packaging provided in dry, clean conditions, away
from direct sunlight, sources of high temperature, petrol and solvent vapours.
Do not store outside the temperature range -30°C to +50°C or with humidity above 90%.
If the product will be stored for an extended period of time before use, the suggested
storage temperature is -4°C to +38°C
When stored as stated, the expected shelf life (prior to use) of the Powered Air Turbo and
the filter is 5 years from date of manufacture. For storage beyond 2 years, the Powered
Air Turbo should be run for at least 10 minutes once a year.
The expected shelf life (prior to use) of the battery is 9 months from date of manufacture.
The original packaging is suitable for transporting the product.
TECHNICAL SPECIFICATION
(Unless otherwise stated in the Reference Leaflet)
Respiratory Protection
EN12941
Nominal and Assigned Protection Factors: please see relevant Headtop User Instructions
Outlet Flow Characteristics
Manufacturers Minimum Design Flow (MMDF) 170 l/min
Audible Alarm
85dB(A) at 10cm
Battery Duration
Standard economy battery pack (11.1V, 2.6 Ah Li metal rechargeable) = 5-6 hour
duration*
High capacity battery pack (11.1V, 4.8 Ah Li metal rechargeable) = 10-12 hour duration*
* New battery and filter at room temperature
Charge Time Standard economy battery pack = approximately 2 hours
High capacity battery pack = approximately 3 hours
Operating Conditions
-10°C to +54°C (54°C limited by battery)
Weight (including high capacity battery, belt and filter)
TR-302E = 1082g
66
67
Publicité
Table des Matières
