Technical Data - Crosswave ED-3.2 EX Mode D'emploi

ED-3.2 EX Pedelec Technical Data
Drive System Pedelec/EPAC
icycle auxiliary actuator with 250W motor, up to
25 km/h, activated through pedal sensor.
Motor BLDC gear motor BLDC stands for Brushless-DC,
i.e., a brushless, electronically commutated 3-
phase direct current motor with a maximum
continuous rated power of 250W.
Controller BLDC motor controller with digital programme
control in accordance with the European standard.
Three different driving modes. In addition, three
geographic profiles P1-P3. The auxiliary actuator
is automatically activated when the pedals are
used, providing assistance up to 25 km/h. The
auxiliary actuator is automatically cut off when the
brakes are applied.
Battery 37V 8.8A h (320 Wh) lithium ion battery made in
Europe with 5 LED capacity display, weight 2.4 kg,
up to 500 charge cycles or 3 – 4 years life expectancy
by optimum usage.
Charging Unit CC-CV charging unit with 2A charging current
full charge of the 9Ah battery lasts approximately
8.8 h.
Operating Highly dependent on the selected operating mode,
Distance
personal mode of operation and other factors.
See Page 134 " Operating range and its Factors"
6 EPAC = Pedelec
106
6
(Electrical Power Assist Cycle)
Malfunctions/Causes/Repair
1. Controller
1.1 The display does not light up after being switched on.
Cause:
Battery incorrectly positioned
Battery defect
Cable/contact error
Electronics defect
1.2 The display unit switches off during the ride.
Cause:
Battery empty
Electronics defect
Plug connection has loosened
2. Battery
2.1 No LED lights up after battery status display has been pressed.
Cause:
Battery empty
Cells in battery pack defective
2.2 The operating distance of the battery has been drastically reduced.
Cause:
The battery is exhausted (aged)
The charger is defective
Charging plug/charging cable damaged
3. Motor
3.1 No performance from the motor but the controller and the battery still function.
Cause:
The motor cable
is disconnected
other cable/contact error
Electronic defective
4. Charging unit
See „Charging and Care of the Battery".
Repair:
>insert the battery again
>contact dealer
>contact dealer
>contact dealer
Repair:
>completely recharge battery again
>contact dealer
>contact dealer
Repair:
>completely recharge battery again
>contact dealer
Repair:
>exchange battery
>contact dealer
>contact dealer
Repair:
>control plug
>contact dealer
>contact dealer