MINN KOTA ULTREX Instructions D'installation page 19

ORIENTATE THE PEDAL CONTROL SLEEvE ASSEMBLY FOR A STARBOARD MOUNT
9
n. Re-tighten the two screws that fasten the Cable
Anchor to the top of the Steering Module using a #2
Phillips screwdriver. Tighten to 25 in-lbs.
10
o. Using a #3 Phillips screwdriver, tighten the Cable
Tension Screw located at the base of the Toe End of
the Foot Pedal to 10 - 12 in-lbs until the Steering
Cables are under tension or re-tighten the same
number of turns as was used in step 4f.
CAUTION
Do not over tighten the Cable Tension Screw, as excessive
tension will cause damage to the unit.
p. Reconfirm that the Steering Cables are tight and
then carefully thread the Steering Motor Connection
Wire through the top of the Wrap Drum Cover. The
male plug comes from the Cable Anchor through
the opening at the bottom of the Wrap Drum Cover.
The wire with the female plug that runs out the top
of the Cable Gear should also be pulled through the
opening at the bottom of the Wrap Drum Cover.
CAUTION
Take care not to pinch the Steering Motor Connection Wire
while the Wrap Drum is set into place.
11
q. Place the Wrap Drum Cover down on top of the
Cable Anchor and align the screw holes on it with
the screw holes on the Cable Anchor. Make sure the
Wrap Drum Cover is nested securely on top of the
Steering Module and that the wires pass out the top
of the Wrap Drum Housing. Secure the Wrap Drum
Housing in place with the two screws that were
originally removed using a #1 Phillips screwdriver.
Tighten to 6 in-lbs.
©2021 Johnson Outdoors Marine Electronics, Inc.
10o
Cable Cable
Tension Tension
Screw Screw
NOTICE:
The Cable Tension Screw does not adjust pedal
tension. Excessive tension on the Cable Tension Screw will
not increase the operating tension of the Foot Pedal.
10p
Wrap Drum Wrap Drum
Cover Cover
Screws Screws
Wrap Drum Wrap Drum
Cover Cover
Wires Wires
Steering Steering
Module Module
Screws Screws
Cable Cable
Anchor Anchor
Toe End of Toe End of
Foot Pedal Foot Pedal
Steering Motor Steering Motor
Connection Wire Connection Wire
Cable Cable
Anchor Anchor
Steering Steering
Module Module
minnkotamotors.com | 19