MINN KOTA ULTREX Instructions D'installation page 16

ORIENTATE THE PEDAL CONTROL SLEEvE ASSEMBLY FOR A STARBOARD MOUNT
2
c. Remove the Connector Cover from the Wrap
Drum Cover using a 1/8" wide Flat Screwdriver to
release it. Release it by pressing the flat part of the
screwdriver in the slot closest to the center of the
Connector Cover and prying upwards.
d. Once the Connector Cover is removed, disconnect
the Steering Motor Connection Plug that is visible.
Steering Motor Connection Plug Steering Motor Connection Plug
2d
Wrap Drum Wrap Drum
Cover Cover
3
e. Remove the two screws that hold the Wrap Drum
Cover in place with a #1 Phillips Screwdriver. Once
removed, lift the Wrap Drum Cover away from the
Steering Module.
CAUTION
Be careful to not damage the Steering Motor Connection
Plug ends and wires.
4
f. The Cable Tension Screw that holds tension on the
Steering Cables is located under the base of the Toe
End of the Foot Pedal. This screw can be loosened
just enough so that the Steering Cables can be
pinched together between the Cable Anchor and
Wrap Drum. Use a #3 Phillips screwdriver to loosen
this screw. Turning the screw approximately 8 turns
counterclockwise should provide enough slack in the
cables to adjust. Keep track of the number of turns
the screw is unscrewed so it can be re-tightened
accordingly later.
CAUTION
Over loosening the Cable Tension Screw may cause the
cables to disengage from the Wrap Drum.
16 | minnkotamotors.com
2c
Connector Connector
Cover Cover
NOTICE:
Please note the orientation and routing of the
plug and wires for re-installation.
Steering Motor Steering Motor
Connection Connection
Plug Plug
Steering Steering
Module Module
Wrap Drum Wrap Drum
Cover Cover
Toe End of Toe End of
Foot Pedal Foot Pedal
Cable Cable
Tension Tension
Screw Screw
NOTICE:
The cables are fed through the Cable Anchor
and wound around the Wrap Drum. The right cable begins
winding on the Wrap drum from the top down. The left cable
begins winding on the Wrap drum from the bottom up.
Flat Flat
Screwdriver Screwdriver
Connector Connector
Wrap Drum Wrap Drum
Cover Cover
Cover Cover
Screws Screws
Steering Motor Steering Motor
Connection Connection
Plug Plug
©2021 Johnson Outdoors Marine Electronics, Inc.