MINN KOTA ULTREX Instructions D'installation page 12

INDEXING THE MOTOR
3
e. Remove the two screws that hold the Wrap Drum
Cover in place with a #1 Phillips Screwdriver. Once
removed, lift the Wrap Drum Cover away from the
Steering Module.
CAUTION
Be careful to not damage the Steering Motor Connection
Plug ends.
4
f. The Cable Tension Screw that holds tension on the
Steering Cables is located under the base of the Toe
End of the Foot Pedal. This screw can be loosened
just enough so that the Steering Cables can be
pinched together between the Cable Anchor and
Wrap Drum. Use a #3 Phillips screwdriver to loosen
this screw. Turning the screw approximately 8 turns
counterclockwise should provide enough slack in the
cables to adjust. Keep track of the number of turns
the screw is unscrewed so it can be re-tightened
accordingly later.
CAUTION
Over loosening the Cable Tension Screw may cause the
cables to disengage from the Wrap Drum.
5
g. Once the Cable Tension Screw is loosened, prying
the Wrap Drum straight up off of the Cable Gear
using a heavy flat-blade screwdriver, until the Wrap
Drum is free of the Cable Gear.
CAUTION
Care must be taken so that the Steering Cables remain on
the Wrap Drum when it is disengaged from the Cable Gear.
It is important that the Steering Cables follow the grooves
on the Wrap Drum so that they do not become intertwined
or pop off. Be sure that the electric wire is not damaged as
the Wrap Drum is lifted.
12 | minnkotamotors.com
Steering Motor Steering Motor
Connection Plug Connection Plug
Steering Steering
Module Module
Wrap Drum Wrap Drum
Cover Cover
Toe End of Toe End of
Foot Pedal Foot Pedal
Cable Cable
Tension Tension
Screw Screw
NOTICE:
The cables are fed through the Cable Anchor
and wound around the Wrap Drum. The right cable is the
shorter cable and begins winding on the Wrap drum from
the top down. The left cable is the longer cable and begins
winding on the Wrap drum from the bottom up.
Wrap Drum Wrap Drum
Flat Flat
Screwdriver Screwdriver
Cable Gear Cable Gear
Screws Screws
Steering Motor Steering Motor
Connection Plug Connection Plug
Cable Cable
Anchor Anchor
Steering Steering
Cables Cables
©2021 Johnson Outdoors Marine Electronics, Inc.