TOHATSU MFS 15E Manuel De L'utilisateur page 62

60
INSPECTION AND MAINTENANCE
Description
Throttle cable
Throttle link*1
Shift/
Throttle
Shift cable
Shift link*1
Power trim & Tilt
Warning system*1
Stop switch
Meters
Bolt, nut
Sliding part
Other /rotation part
Grease nipple
Outer equipment
Anode (engine)
Anode
(except for engine)
Top cowl/Ratch
*1" " This procedure can be performed by end user (or dealer)
*2" " This procedure shall be carried out by the dealer.
ENON00030-0
Note
Your outboard motor should receive careful, and complete inspection at 300 hours. This is the best
time for major maintenance procedures to be carried out.
ENOM00091-A
Engine oil replacement
Engine oil mixed with dust or water will
10
dramatically shorten the life of the engine.
ENOW00091-0
You may be injured due to high engine
temperatures if you fill engine oil just after
stopping. Changing engine oil should be
done after the engine has been cooled.
ENOW00092-0
Do not overfill engine oil, or engine oil
could leak and/or engine could be dam-
aged. If engine oil level is over upper
limit marks of oil gauge, drain oil to level
lower than upper limit.
Inspection intervals
First 20 Every 50 Every 100
hours or hours or hours or
1 month 3 months 6 months
/ /
/
CAUTION
CAUTION
Every 200 Every 400
Inspection procedure
hours or hours or
1 year 2 year
Check and replace if necessary
Check and adjustment
Check and replace if necessary
Check and adjustment
Check /Replenish
Check
Check
Check
Retighten
Apply grease
Pump in grease
Check
Check and replace if necessary
Check /Replace if necessary
/ Check / Adjustment
Be sure that outboard motor is in upright
and level position when checking or
changing oil.
Stop engine immediately if low oil pres-
sure warning lamp is lit or oil leak is
found, or engine could be severely dam-
aged. Consult dealer.
Wipe off engine oil well immediately if
spilled and dispose of it in accordance
with local fire prevention and environ-
ment protection regulations.
ENOW00090-0
Use of engine oils that do not meet these
requirements will result in reduced engine
life, and other engine problems.
Remarks
Refer to P69
Refer to P70
Refer to P70
Refer to P68
Refer to P68
CAUTION