Material Composition And Recyclability; Fuel Cell Model - Operating Instructions - Advance CS7000 Mode D'emploi

Type
Aluminum
Electrical / motors / engines - misc
Ferrous metals
Harnesses / cables
Liquids
Plastic - non-recyclable
Plastic - recyclable
Polyethylene
Rubber
CS7000 FUEL CELL MODEL – OPERATING INSTRUCTIONS
Operation:
• Do not turn the fuel cell module off while the machine is in operation!
module off.
• For operating, refueling, safety, or service information speci c to the fuel cell module, refer to the manufacturer's publications.
• The following fuel cell hybrid modules have been evaluated and are approved for use in this equipment:
• Plug_Power, Inc. model 2300 Gen-Drive hybrid fuel cell module
• Limitations: The fuel cell module listed above is intended for use in normal warehouse or other moderate-duty
applications. It is intended for indoor use only. It may not be suitable for severe-duty applications such as rough
surface cleaning/sweeping or severe inclines.
• For operating, safety, or service information speci c to the CS7000, refer to the appropriate Nil sk documentation.
Cleaning of Machine:
• FUEL CELL MODULE SHOULD NOT GET WET!
machine operating manual with the following important note: The fuel cell module should not be subjected to water or solution spray or
indirect contact.
• Do not spray or pour water over the top of the machine as liquid may run between machine panels onto the fuel cell module.
• Keep water spray below the fuel cell compartment.
• Do not spray water or solution into the side grille openings.
Fuel Cell Installation or Removal:
• Follow standard battery installation and removal procedures. Module must be installed or removed using a battery roll-out cart with
minimum capacity rating of 2300 LBS (1050 kg).
• Install the module with the refueling port on the operator side of the machine.
Installation or Removal of Fuel Cell Module User Interface Panel:
• Refer to instruction sheet number 56090146
revised 8/2013

Material Composition and Recyclability

% of machine weight % of machine weight
Gasoline/Petrol / LP
0.5%
27%
53.8%
1.1%
0.7%
1.5%
0.9%
12%
2.5%
Cleaning of the CS7000 should be done in accordance with instructions in the
% of machine weight
Diesel Battery
0.5% 0.3%
29.3% 50.1%
51% 35.2%
1.2% 0.9%
0.7% 0.9%
1.8% 1.1%
0.7% 0.4%
12.3% 9.2%
2.5% 1.9%
Always turn the machine off rst, and then turn the fuel cell
FORM NO. 56041979 - CS7000 - A-41
ENGLISH / A-41
% recyclable
88%
95%
95%
74%
95%
0%
91%
100%
60%