Troubleshooting; Replacement Parts Pb2Bpgg & Grill Cart - Pit Boss PB2BPGG Manuel De L'utilisateur

TROUBLESHOOTING

Proper cleaning and maintenance will prevent common operational problems. When your grill is operating poorly, or on a less
frequent basis, the following troubleshooting tips may be helpful. For FAQ, please visit www.pitboss-grills.com . You may also
contact your local dealer or Customer Service for assistance.
WARNING: Always ensure the grill is completely cooled to avoid injury.
PROBLEM CAUSE SOLUTION
Burner Will Not Light The ignition wire is broken Contact Customer Service for assistance or a replacement part.
No igniter spark on electrode Adjust the electrode. Contact Customer Service for assistance or a replacement part.
No gas supplied Check the regulator valve. Check connection for leak.
Grease Fire / Frequent Grilling fatty meats Grill fatty meats when the cooking surface is cold, and the knobs are on the "LOW" setting.
Flare-Ups
Cooking temperature Attempt cooking at a lower temperature. Grease does have a flash point. Keep the
temperature under 176°C / 350°F when cooking highly greasy food.
Water sprayed on gas flames Do not spray water on gas flames.
Burner blows out No Gas Flow Check gas fuel connection, and ensure it is open. Replace gas cylinder if empty.
Gusting or High Winds Turn front of grill away from wind or increase flame height.
Low heat on "HIGH" Ports blocked Clear ports of any obstructions.
Gas cylinder empty Refill the gas cylinder.
Gas Leakage Improper Installation Turn the regulator knob to the OFF position, and allow the regulator knob to pop out. Remove
the gas cylinder. Re-install and tighten. Perform leak test to ensure proper seal. Replace gas
cylinder if damaged.
Seal Failure Gas cylinder has corroded, rusted, or has been mishandled. Replace gas cylinder.
Regulator Failure Regulator needs to be replaced. Contact Customer Service for a replacement part.
Burner Flames Are Poor Air Flow Check burner tube and burner ports for spider webs or other obstructions. Follow Care and
Maintenance instructions to clean the burner tube.
Yellow Or Orange
Burner Obstruction
Grease Cup Is Full, Spilling Empty grease cup and re-install. Follow Care and Maintenance instructions.
Regulator Valve Is Off Check the regulator valve connection to the gas cylinder. Remove, then reinstall. Perform leak
test.
Burner Is Dirty Turn regulator knob to HIGH for five minutes, and burn-off the unit. Follow Care and
Maintenance instructions.
10
REPLACEMENT PARTS -
REPLACEMENT PARTS - PB2BPGG & GRILL CART
Part# Description Part# Description
1 Lid (x1) A Screw (x11)
Part# Description
2 Lid Handle (x1) B Self-tapping Screw (x3)
1 Lid (x1)
3 Thermometer Bezel (x1) C Screw (x4)
Lid Handle (x1)
2
4 Thermometer (x1) D Screw (x4)
3 Thermometer Bezel (x1)
5 Cooking Grid (x2) E Wheel Bushing (x2)
4 Thermometer(x1)
6 Body Support (x2) F Nut (x5)
5 Cooking Grid (x2)
7 Side Shelf (x2) G Cotter Pin (x2)
6 Body Support (x2)
8 Cotter Pin (x2) H Allen Key (x1)
Side Shelf (x2)
7
9 Lid Pin (x2) I Wrench (x1)
8 Cotter Pin（x2）
10 PF Pad (x8)
9 Hood Pin (x2)
11 Body (x1)
10 PF Pad(x8)
12 Body Support Beam (x2)
11 Body (x1)
13 Left Burner (x1) 12 Body Support Beam (x2)
5
14 Burner Crossover (x1) Burner (left) (x1)
13
15 Right Burner (x1)
14 Crossover (x1)
15 Burner (right) (x1)
16 Grease Tray Support (x1)
17 Grease Tray (x1) 16 Grease Tray Support (x1)
17 Grease Tray (x1)
18 Aluminum Foil Liner (x1)
20
Aluminum foil liner (x1)
18
19 Bracket (x1)
19 Bracket (x1)
20 Valve Assembly (x1)
Valve Assembly (x1)
20
21 Control Knob (x2)
21
22
21 Control Knob (x2)
22 Front Panel (x1)
22 Front Panel (x1)
23 Cart Top (x1)
23 Cart top panel (x1)
24 Gas Cylinder Hook (x1)
24 Gas bottle hook(x1)
25 Accessory Tray (x1)
25
25 Condiment basket (x1)
26 Cart Front Panel (x1)
26 Cart front panel (x1)
27 Stationary Cart Leg - Front (x1)
27 Left front leg (x1)
28 Stationary Cart Leg - Back (x1)
Left back leg(x1)
28
29 Cart Leg For Wheel - Front (x1)
Right back leg (x1)
29
26
30 Cart Leg For Wheel - Back (x1)
Right front leg (x1)
30
31 Bottom Shelf (x1)
31 Bottom panel (x1)
32 Axle Pin (x2)
32 Axle Pin(x2)
33 Wheel (x2)
33 Wheel (x2)
34 Cart Leg Cap (x2)
34 Cart Leg Cap(x2)
M6X15 Screw (x11)
A
B Self-tapping Screw (x3)
C M6X50 Screw (x4)
D
M6X40 Screw (x4)
E Wheel Bushing(x2)
F Nut (x5)
G Cotter Pin (x2)
K M6 Allen Key (x1)
MODEL ASSEMBLED (WxDxH)
I Spanner (x1)
1,175 X 578 X 461 MM /
PB2BPGG
46.2 X 22.7 X 18.1 IN
PB
691 X 706 X 645 MM /
GRILL CART
27.2 X 27.8 X 25.4 IN
NOTE: Due to ongoing product development, parts are subject to change without notice.
PB2BPGG & GRILL CART
1
2
6
3
4
10
9
8 7
12
13
14 15
11
19
17
16
18
23
24
A
B
32
28
30
C
33
D
29
E
F
27
G
H
I
34
33
32
WEIGHT COOKING AREA HEAT INPUT
18.0 KG / 1,946 CM² /
5.2 KW
39.68 LB 301.6 IN²
8.0 KG /
17.6 LB
11