Safety Information - Pit Boss PB2BPGG Manuel De L'utilisateur

SAFETY INFORMATION

A MAJOR CAUSE OF FIRES ARE A RESULT OF POOR MAINTENANCE AND A FAILURE TO MAINTAIN
REQUIRED CLEARANCES (AIR SPACES) TO COMBUSTIBLE MATERIALS. IT IS OF UTMOST IMPORTANCE
THAT THIS PRODUCT BE INSTALLED ONLY IN ACCORDANCE WITH THESE INSTRUCTIONS.
Please read and understand this entire manual before attempting to assemble, operate or install the product. This will ensure
you receive the most enjoyable and trouble-free operation of your new portable gas grill. We also advise you retain this manual
for future reference.
DANGERS AND WARNINGS
1. A minimum clearance of 915mm (36 inches) from combustible constructions to the sides of the grill, and 915mm (36 inches)
from the back of the grill to combustible constructions must be maintained. Do not use this appliance indoors or in an
enclosed, unventilated area. This appliance must not be placed under overhead combustible ceiling or overhang. Keep your
grill in an area clear and free from combustible materials, gasoline and other flammable vapors and liquids.
Should a grease fire occur, turn the grill OFF until the fire is out. Do not throw water on. Do not try to
smother the fire. Use of an all-class (class ABC) approved fire extinguisher is valuable to keep on site. If an
uncontrolled fire does occur, call the Fire Department.
2. This outdoor grill is not intended for installation in/on recreation vehicles or boats.
Never use this appliance in an enclosed space, such as a camper, tent, car, boat or home. This appliance is
not intended for and should never be used as a heater.
3. This appliance is not recommended for children, persons with reduced physical, sensory or mental capabilities, or lack of
experience and knowledge, unless they are under direct supervision or instruction by a person responsible for their safety.
4. Parts of the barbecue may be very hot, and serious injury may occur. Keep young children and pets away while in use. Do not
touch hot surfaces. Use heat-resistant gloves, long-handled tongs, or cooking mitts at all times, since the grill will become
very hot.
5. Never use the grill without the grease cup installed and hung under the firebox. Without the grease cup, hot grease and debris could
leak downward and produce a fire hazard.
6. Do not obstruct the flow of combustion and ventilation air to this appliance. Keep the burner tube and portholes clean and
free from debris. Clean before use. Regular care and maintenance is required to prolong the lifespan of your unit.
7. Always check for gas leaks when you connect and disconnect the regulator to the gas cylinder, especially after a period of
storage (for example, over winter). Check all connections for leaks with a soapy water solution and brush. Never use an open
flame to check for leaks.
8. Clean and inspect the gas regulator before each use of the outdoor cooking gas appliance. Replace the gas regulator prior to
being used if there is evidence of excessive abrasion or wear.
9. Operate this appliance using liquefied petroleum only, which is also specified on the rating label on the unit. Do not attempt
to operate your grill on other gases. Do not attempt to convert this LP unit to natural gas. Failure to follow this warning could
lead to fire, bodily harm, and will void your warranty.
2
PROPANE GAS WARNINGS
1. Ensure the gas cylinder is purchased by a reputable supplier. An incorrectly filled or an overfilled gas cylinder can be dangerous.
The overfilled condition combined with the warming of the gas cylinder (a hot summer day, gas cylinder left in the sun, etc.)
can cause LP gas to be released since the temperature increase causes gas to expand. Gas released from the cylinder is
flammable and can be explosive.
2. Do not use an LP gas cylinder if it has a damaged valve or shows signs of dents, gouges, bulges, fire damage, corrosion,
leakage, excessive rust, or other forms of visual external damage; it may be hazardous and should be checked immediately
by a liquid propane supplier.
If you see, smell, or hear the hiss of gas escaping from the cylinder, do not attempt to light appliance.
Extinguish any open flame. Disconnect from fuel supply.
3. Do not connect or disconnect the gas cylinder while the unit is in use or is still hot. When grill is not in use, ensure regulator
knob is turned to OFF and disconnect the gas cylinder. Never move or transport the unit while the gas cylinder is attached.
Do not store a spare LP gas cylinder under or near the appliance.
4. Parts sealed by manufacturer shall not be manipulated by the user. Do not move the appliance during use. Turn off the gas
supply at the gas cylinder after use. Do not modify the appliance.
CARBON MONOXIDE ("the silent killer")
Always use a gas appliance outdoors in an open area with good ventilation to avoid breathing toxic fumes from combustion or
leaking gas. Carbon monoxide is a colorless, odorless, tasteless gas produced by burning gas, wood, propane, charcoal or other
fuel. Carbon monoxide reduces the blood's ability to carry oxygen. Low blood oxygen levels can result in headaches, dizziness,
weakness, nausea, vomiting, sleepiness, confusion, loss of consciousness or death. Follow these guidelines to prevent this
colorless, odorless gas from poisoning you, your family, or others:
• See a doctor if you or others develop cold or flu-like symptoms while cooking or in the vicinity of the appliance. Carbon
monoxide poisoning, which can easily be mistaken for a cold or flu, is often detected too late.
• Alcohol consumption and drug use increase the effects of carbon monoxide poisoning.
Carbon monoxide is especially toxic to mother and child during pregnancy, infants, the elderly, smokers, and people with blood
or circulatory system problems, such as anemia, or heart disease.
SAFETY LISTING
In accordance with the procedures and specifications by Conformité Européenne (CE), Pit Boss® Grills
gas appliances demonstrates compliance through testing to the standards and directives that comply
with all safety, health and environmental protection requirements by the EU (European Union) and the
European Economic Area (EEA).
HEAT INPUT BURNERS INJECTOR SIZE
5.2 KW 0.79mm
PB2BPGG
G30 – 378 g/h 2 0.74mm
G31 – 372 g/h 0.69mm
7.5 KW 0.90 / 0.70mm
PB3BPGG
G30 – 546 g/h 3 0.86 / 0.65mm
G31 – 536 g/h 0.80 / 0.60mm
GAS/PRESSURE COUNTRY OF USE
G30 at 28-30 mbar
G31 at 37 mbar
I : BE, CY, CZ, EE, FR, GR, IE, IT, LV, LT,
3+ (28-30/37)
G30/G31 mixture at 30 mbar
LU, PT, SK, ES, CH, GB, RO
G30/G31 mixture at 37 mbar
G30/G31 mixture at 50 mbar I : BG, CY, CZ, DK, EE, FI, GR, HR, HU,
3B/P (30)
LV, LT, LU, MT, NL, NO, SK, SI, SE, TR, IS
G30 at 28-30 mbar
G31 at 37 mbar
I : PL
3B/P (37)
G30/G31 mixture at 30 mbar
I : AT, DE, HU, SK, CH
G30/G31 mixture at 37 mbar 3B/P (50)
G30/G31 mixture at 50 mbar
3