Charging The Battery - DeVilbiss Healthcare drive Casalift 18001 Manuel D'utilisation

Foreword Battery
Introduction Charge indicator
1 6.3.2 Foreword Operating the brakes
1.1 Introduction
The Casalift 180 is a lightweight and versatile lift device for use in patient and A
geriatric care situations. Use of the lift is facilitated considerably by its spreading
travel leg design. After use, or for transport by car, it can be dismantled.
This manual was produced based upon the information available on the design
and operation of the Casalift which was available at time of printing. We reserve
the right to make changes due to technical advances.
(A) To lock the wheel brakes.
Should you have any questions concerning the Casalift, please contact your spe-
cialist Days Healthcare dealer (see dealer's stamp on the back of the envelope).
6.3.3 Operating the boom
Press the button for the desired direc-
1.2 Intended use
tion.
The Casalift 180 should be use exclusively for the purpose of lifting and moving
• Lift the boom (A)
persons in need of care. It is only designed to move patients over short
• Lower the boom (B)
distances.
Improper use will lead to the exclusion of the manufacturer's liability.
Note
The Casalift may only be used by persons who have received instruction from the
• The boom can be repositioned 15 to 40 times between battery charges, de-
owner, and under consideration of the condition of the patient being transport-
pending on the weight of the individual.
ed. In borderline cases, or if in doubt, consult the attending doctor.
• When the boom reaches its end position, or if it is blocked by an obstacle,
the control module switches the lifting motor off.
Restriction on use!
Patients who are heavier than 180 kg must not be lifted with the Casalift.
7 Battery
1.3 Information on the operating manual
7.1 Charge indicator
1.3.1 Symbols used in the operating manual
The operating controls provide an indication of the current charging status of
the battery. If a beep sounds when a button is pressed, the battery is 50% dis-
The following symbols are used in the operating manual to identify particular
charged. Recharge the battery after this use.
hazards in using the product or information to simplify usage.
7.2

Charging the battery

Caution!
This symbol identifies safety instructions which highlight risks in using the prod-
7.2.1 Charging information
uct.
• The battery must be charged for at least 10 hours before the first use.
• The battery must be charged once a month even if the product is not being
Caution!
used, as it will otherwise discharge itself over the course of time, eventually
This symbol identifies safety instructions which highlight risks of crushing and
becoming deeply discharged and therefore no longer serviceable.
trapping when using the product.
• The ambient temperature should be between 10 and 30°C. In lower temper-
atures, charging takes longer.
• Only charge the battery in dry environments.
GB – 20 GB – 28
30
B
(B) to release the wheel brakes.
A
B
Casalift 140E / 180E – 15.10.2010 Casalift 140E / 180E – 15.10.2010
Casalift 180 - SEPTEMBER 2017
Battery Safety
Charging the battery Safety instructions
• The charger has an automatic shut-off function, which prevents the battery
from being overcharged.
Note
• The Casalift must not be used for moving patients during the charging proc-
Under this symbol, you can find helpful information on using the product.
ess.
• Depending on the amount by which the battery is discharged, the charge
1.3.2 Information on the operating manual
time will be between 5 and 14 hours.
Carefully read through the operating manual before assembling the Casalift and
7.2.2 Connecting the charger
bring it into service!
1. Plug adaptor into the socket on the Make sure that:
control module.
• all persons who are to use the Casalift have read the operating manual.
2. Plug connector (A) of the charging • all persons charged with setting up or maintaining the Casalift always have
cable into the adapter. access to the operating manual.
3. Plug mains plug of the charging cable Damage caused through a failure to follow the information in the operating
manual is excluded from any and all warranty claims. into a socket (230 V~/50Hz).
The illustrations which appear in this operating manual are only examples of
After charging:
how to use Days Healthcare patient lifts, and may differ from your actual model.
1. Pull the mains plug of the charging
cable out of the socket.
2 Safety
2. Pull connector (A) of the charging ca-
ble out of the adapter.
2.1 Safety instructions
3. Pull adapter out of the socket on the
control module.
2.1.1 Safety instructions – General
Caution!
Risk of accident!
Pay particular attention to the order of the steps when connecting and discon-
• Only use the Casalift for its intended use. The Casalift is not a piece of gym-
necting the charging cable.
nastics or playground equipment.
• Only use the Casalift if it is in a technically sound condition.
7.2.3 LEDs on the control module
• Only use slings, sling seats or reclined slings which are in perfect condition. Replace
• LED (A) lights up green and LED (B)
sling systems which are damaged or heavily worn immediately!
lights up orange:
• All faults which have a bearing on the function and safety of the Casalift
On charge
must be rectified without delay by a specialist dealer.
• LED (A) lights up green and LED (B)
does not light up:
2.1.2 Safety instructions – Assembly
Fully charged
Risk of trapping! Risk of crushing!
• There is an increased risk of trapping and crushing at all joints of the Casalift.
• While assembling the product, pay particular attention to these danger
points.
Casalift 140E / 180E – 15.10.2010 Casalift 140E / 180E – 15.10.2010
Casalift 180 - SEPTEMBER 2017
A
A B
GB – 29 GB – 21
31