Maintenance Schedule & Daily Check List - Sunrise Medical Oxford Manuel De L'utilisateur Et Garantie

E n g l i s h
8. MAINTENANCE SCHEDULE & DAILY CHECK LIST
All Oxford/Hoyer products are designed for minimum maintenance, however some safe-
ty checks and procedures are required. A schedule of DAILY tasks is detailed below.
Daily checks and a six monthly service, inspection and test will ensure a lift is kept in
optimum safe working condition. A list of spare parts is available upon request.
The LOAD TEST and certification should only be carried out by qualified personnel or
an authorised service agent / dealer.
DAILY CHECK LIST: Sunrise Medical strongly recommends the following checks be
carried out on a daily basis and before using lift.
• MAKE sure the lift moves freely on its castors.
• MAKE sure the spreader bar is free to rotate and swing
• EXAMINE the spreader bar/cradle is firmly attached to the boom.
• EXAMINE the sling hooks/clips on the spreader bar/cradle and side suspenders for
excessive wear.
• MAKE sure the legs open and close correctly.
• OPERATE the hand control to confirm the boom raises and lowers satisfactorily.
• ON electric powered lifts check the operation of the emergency stop button.
• EXAMINE slings for fraying or other damage. DO NOT use any sling if damaged or
if the sling shows signs of wear.
• CONFIRM the lift is not giving a low battery alarm when the hand control is oper-
ated. If the alarm sounds, DO NOT use, and place on charge immediately.
• CHECK fasteners for tightness and wear.
MAINTENANCE, INSPECTION AND TEST
Sunrise Medical recommend a thorough inspection and test of the Oxford/Hoyer
Stature lift and lifting accessories, slings, scales etc is carried out on a regular basis.
Inspection frequency varies from country to country so you must check with your deal-
er or local government agency how often an inspection is required. The examination
and test should be conducted according to the recommendations and procedures
below. Sunrise Medical recommends maintenance, inspection and certified testing is
carried out by authorised service agent / dealers only.
NOTE–
These recommendations are in compliance with the requirements of 1998 No2307 Health
and Safety: The Lifting Operations and Lifting Equipment Regulations 1998. This is a UK
regulation. Outside the UK please check your local country requirement.
19
294000.10017 Rev. B