Failure Diagnosis; Scrap - Erreka DOLFIN Manuel De L'utilisateur

3

FAILURE DIAGNOSIS

Problem
The operator does not make
any movement when the key
devices are activated
The gate does not open
(the display shows C4 or Ftço)
The gate does not close
(the display shows C5 or Ftço)
The gate cannot completely
close (or open)
4

SCRAP


The operator, up until the end of its useful life,
must be dismounted at its location by an
installer who is as well qualified as the person
who completed the assembly, observing the
same precautions and safety measures. In this
manner possible accidents and damage to
adjacent facilities will be avoided.
Cause
Absence of system power supply
voltage
Electrical installation defective
The key for manual operation is in
unlock position (the display shows
StOP)
The transmitter radio code is not
recorded in the operator
The transmitter batteries are flat
The closing safety device (photocell or
strip) or its cabling are open or defective
The opening safety device (photocell or
strip) or its cabling are open or defective
The resistance of the gate has increased
when closing (or when opening)
The thrust of the operator during
closing (or opening) is too low
The belt is not correctly taut.
The gate open/close programming has
not been carried out correctly
MAINTENANCE AND DIAGNOSIS OF FAILURES
Solution
Reestablish the power supply
Check that the installation does
not present any short-circuits or
cut-off points
Position the key in locking position
for motorised operation
Correctly record the radio code
Replace the batteries
Check the cabling and device
(photocell or safety strip)
Check the cabling and device
(photocell or safety strip)
Check the moving parts of the gate
and remove the resistance
Using programming, increase the
opening or closing thrust
Tighten the belt correctly
Correctly programme the open/
close
}
The operator must be deposited in the appropriate
containers for subsequent recycling, separating and
classifying of the different materials in line with their
nature. NEVER deposit it in domestic rubbish or in
landfills which are not suitably controlled, as this will
cause environmental contamination.
DOLFIN operator for sliding gates
65