Table des Matières
Publicité
INSP
ADJ
MAINTENANCE INTERVAL CHART
The following chart should be considered strictly as a guide to general maintenance intervals.
Depending on operating conditions, the intervals of maintenance should be changed.
Item
CONTROL SYSTEM
Steering cable
Steering master
Throttle cable
Carburetor throttle shaft Inspect/adjust
Choke cable
Shift cable
QSTS cable
YPVS cable
FUEL SYSTEM
Fuel tank
Fuel filter
Fuel line
Trolling speed
Carburetor setting
OIL INJECTION SYSTEM
Oil injection system
Oil pump cable
POWER UNIT
Spark plugs
Cooling water passage
Rubber coupling
ELECTRICAL
Battery
JET PUMP UNIT
Impeller
Water inlet strainer
Bilge strainer
GENERAL
Bolts and nuts
Drain plugs
Lubrication points
Intermediate housing
*1: After every ride
*2: Inspect fluid level before every ride
*3: Grease capacity 33.0–35.0 cm
*4: Grease capacity 6.0–8.0 cm
MAINTENANCE INTERVAL CHART
Remarks
Inspect/adjust
Inspect
Inspect/adjust
Inspect/adjust
Inspect/adjust
Inspect/adjust
Inspect/adjust
Clean
Clean/replace
Inspect
Check/adjust
Inspect/adjust
Check/clean
Inspect/adjust
Inspect/clean/adjust
Inspect/clean
Inspect
Inspect
Inspect
Clean
Clean
Retighten
Inspect/replace
Grease
Grease
3
(1.11–1.18 oz)
3
(0.20–0.27 oz)
Initial
10 hours
50 hours
(Break-in)
(3 months)
*1
*2
*3
3-1
Every
Refer to
100 hours
200 hours
(6 months)
(1 year)
*4
E
page
3-2
3-2
3-3
—
3-4
3-6
3-4
3-7
4-10
3-8
3-8
3-9
4-16
3-10
4-29
3-10
—
—
3-11
3-14
3-15
3-15
—
3-15
3-16
3-18
Publicité
Chapitres
Table des Matières
