Publicité
7 Maintenance
7.1
General maintenance
INFO: INSPECTING THE STOVE
The stove must be inspected to prevent defects and ensure safe operation:
► Have your stove professionally inspected at least 1x per year.
NOTE: REGULAR MAINTENANCE
Regular maintenance must be carried out on your stove to ensure that it functions properly.
7.2
Maintenance overview
6
13
12
6
6
Flue pipe
Door mechanism
1
6
Surfaces
Fire grate
2
7
3
Baffle plate
8
Ash drawer
4
Temperature sensor
9
Ash drawer seal
5
Firebricks
10
Control panel
7.3
Stove parts listed in the service and cleaning schedule get very hot during operation:
Your stove requires regular maintenance to ensure it is working properly.
The items in table "Service and lubrication schedule" depend on the following factors:
Fig. 17
If the door seals are damaged or worn, toxic flue gases can escape from the stove:
Blocked chimneys produce toxic fumes that can enter the living area:
1
Service and lubricating schedule
2
12
2
3
10
4
13
9
7
5
8
5
6
11
7
5
1
8
6
9
3
10
4
11
*If damaged and there are obvious leaks.
**Always vacuum with an industrial vacuum with ash separator.
Fig. 18
***Included in the starter kit and available from your HASE authorised dealer.
Ash compartment
11
Firebox glass
12
13
Firebox door seal
Maintenance
CAUTION: HOT STOVE PARTS
► Always perform maintenance with the stove completely cooled
down.
NOTE: ROUTINE MAINTENANCE
▪ Fuel quality
▪ Intensity of use
▪ Heating patterns
▪ Legal requirements
WARNING: DAMAGED DOOR SEALS
► Never use your stove if the seals on the
firebox door are worn or damaged.
► Replace worn or damaged seals before using your stove again.
WARNING: TOXIC GASES
► The chimney and flue must be free of obstructions.
► Clean the flue pipe regularly.
► Have the chimney cleaned regularly by a specialist.
► Only use recommended fuels.
► Read and follow the operating instructions.
MAINTENANCE POINT
TO DO
Firebox glass
Clean
Surfaces
Clean
Control panel
Clean
Firebox door seal
Check/replace
Ash drawer seal
Check/replace
Fire grate
Sweep/vacuum**
Ash drawer
Empty/vacuum**
Firebricks
Sweep/vacuum**
Ash compartment
Vacuum**
Firebricks
Check
Flue pipe
Check/sweep
Door mechanism
Grease
Chimney
Have cleaned
Baffle plate
Clean flue gas path
Temperature sensor
Brush
en
WITH WHAT?
FREQUENCY
Paper towel
as required
Paper towel
as required
Cloth
as required
New seal
as required*
New seal
as required*
Broom/ash vacuum
Daily
Broom/ash vacuum
Daily
Broom/ash vacuum
Monthly
Ash vacuum
Monthly
Eyes
Annually
Broom
Annually
Speciality grease***
Annually
Chimney sweep
Annually
Brush
Annually
Brush
Annually
93
Publicité
