EBARA EVM Série Manuel D'utilisation Et D'entretien page 12

INSTRUCTION MANUAL REGARDING USE AND MAINTENANCE
INDEX
1. INTRODUCTION
2. MANUFACTURER IDENTIFICATION DATA
3. GUARANTEE AND TECHNICAL ASSISTANCE
4. general saFeTy Warnings
4.1 PreVenTiVe measures To Be Taken By THe user
4.2 IMpORTANT pROTECTIONS AND CAUTIONS
4.3 RESIDUAL RISkS FOR SURFACE pUMpS
GB
5. HANDLING AND STORAGE
6. TECHNICAL-pRODUCTION CHARACTERISTICS
6.1 DESCRIpTION
6.2 USE FOR wHICH pUMpS ARE DESIGNED
6.2.1 USE OF DRINkING wATER
6.3 USE FOR wHICH pUMpS ARE NOT DESIGNED
7. SpECIFICATIONS
7.1 pUMp SpECIFICATIONS
7.2 MOTOR SpECIFICATIONS
7.3 pUMp RATING pLATE
7.4 INFORMATION ON AIRbORNE NOISE
8. pREpARING FOR USE
8.1 COUpLING TO THE MOTOR
8.1.1 ASSEMbLING THE MOTOR TO THE pUMp
8.2 GENERAL INSTALLATION pRECAUTIONS
8.2.1 INSTALLATION
8.2.2 pOSITIONING THE pRODUCT
8.2.3 FASTENING DOwN
8.2.4 pIpEwORk
8.3 FLANGE LOADING AND TIGHTENING TORQUES
9. ELECTRICAL CONNECTION
10. FILLING THE pUMp
10.1 FILLING pUMp IN SUCTION LIFT ARRANGEMENT
10.2 FILLING pUMp IN A FLOODED INSTALLATION
11. USE AND STARTING
11.1 GENERAL wARNINGS
11.2 STARTING
11.3 RUNNING
11.4 STOppING
12. MAINTENANCE AND REpAIRS
12.1 REpLACEMENT OF SHAFT SEAL
13. DISpOSAL
14. TROUbLESHOOTING
15. SUppLIED TECHNICAL DOCUMENTATION
To Be kePT By THe user
1. INTRODUCTION
Observe the instruction contained therein to obtain best results from the
product. if you need further information, get in touch with your nearest au-
thorized dealer.
NO PART OF THESE ILLUSTRATIONS AND/OR TEXT MAY BE REPRO-
DUCED FOR ANY REASON.
The following symbols have been used in the compilation of this instruction
booklet to make the reader aware of what can happen if instructions are not
complied with:
WARNING!
Risk of damaging the pump or system
Risk of causing injury or damaging property
Electrical hazard
12
2. MANUFACTURER IDENTIFICATION DATA
2.1 MANUFACTURER DATA
EBARA Pumps Europe S.p.A.
page 12 Plant management:
Via pacinotti, 32 - 36040 brendola (VI), ITALIA
page 12
Telefono: 0444/706811 - Telefax: 0444/706950 - Telex: 480536
page 12
Registered office:
page 12
Via Campo Sportivo, 30 - 38023 Cles (TN), ITALIA
page 12
Telefono: 0463/660411 - Telefax: 0463/422782
page 13
page 13
page 13 2.2 See NAMEPLATE chapter 7.3
page 13
page 13
3. GUARANTEE AND TECHNICAL ASSISTANCE
page 13
page 13
FAILURE TO OBSERVE THE INSTRUCTIONS GIVEN IN THIS MANUAL AND
page 13
WORK DONE ON THE PRODUCT BY ANYONE OTHER THAN OUR SERVICE
page 14 CENTRES VOID THE WARRANTY AND RELIEVE THE MANUFACTURER OF
ALL LIABILITY FOR PERSONAL INJURY AND DAMAGE TO THE PRODUCT.
page 14
page 14
when you receive the product, make sure that the packaging has not been
page 14
damaged externally (breaks/large dents); if so, immediately report the
page 14
damage to the shipping agent. Remove the product from its packaging and
page 14
check it for shipping damage; report any such damage to the retailer within
page 15
8 days of delivery. Check that the ratings on the product's nameplate match
page 15
those of your order.
page 15 The following parts, being normally subject to wear, have a limited guaran-
tee:
page 15
• bearings
page 15
• mechanical seals
page 15
• grommets
page 15
• capacitors
page 16
If a fault that is not listed in the "TROUbLESHOOTING" table (chapter 14)
page 17
occurs, please contact the nearest authorised retailer.
page 17
page 17
4. GENERAL SAFETY WARNINGS
page 17
page 17
Before using the product, you must be sure you can follow the instructions
page 17
given in this manual and apply them whenever using or servicing it.
page 17
page 17
4.1 PREVENTIVE MEASURES TO BE TAKEN BY THE USER
page 18
page 18
The user must observe all local safety and accident pre-
page 18
vention regulations; he must also observe the product's
page 18
specifications (see "TECHNICAL DATA").
page 18
Always wear protective gloves when handling the pump or
page 20
performing maintenance.
When repairing or servicing the product, shut off its power
supply to prevent the risk of accidental startup, which can
result in injury and damage.
The device can be used by children aged above 8 years
and by persons with reduced physical, sensory or mental
abilities, or who lack adequate experience and knowledge
of the product, provided that they are supervised or have
been adequately instructed on its safe use and the rele-
vant risks involved. Children must not play with the device.
Cleaning and maintenance to be carried out by the user
must not be effected by unsupervised children.
Attempting to service, install or handle the product while
its electrical equipment is live can result in serious and
even fatal injury.
When starting up the product, make sure you are wearing
shoes, not standing in water, and that your hands are dry.
Users must not operate or carry out any work on the motor-
driven pump that is not permitted in this manual.