Mosa GE 2500 SR FAMILY Mode D'emploi page 48

© MOSA REV.0-01/08
PROCEDURE FOR RECHARGING A BATTERY
Take off the breather caps of the battery.
If necessary, add up distilled water to have the liquid
at the recommended level.
Put back the breather caps of the battery.
WARNING
!
Sulfuric acid is corrosive. Protect hands,
eyes and clothes.
Take the battery out of the machine for
filling.
Warranty VOIDED for damages due to spilled acid.
Use a densimeter to determine the charge state of
the battery.
SPECIFIC
WEIGHT
1.265
1.230
1.200
1.170
WARNING
• Do not try to start the engine, of a motor car, when
the generator is still connected to the battery.
• The generator may be damaged.
• Connect the positive terminal of the battery to the
positive re-charge cable.
Do not invert the cables otherwise severe da-
mages may occur to either the generator or the
battery.
When the battery is out of the machine (the car)
take the following steps. A spark close to the battery
might cause an explosion.
To reduce this risk:
1. Check the polarity of the battery.
The positive pole (Pos +) of the battery has usually
a diameter larger than that of the negative (Neg-).
2. Connect an insulated cable having a section of
13 sq.mm. and a minimum length of 600 mm. to
the negative pole (Neg-).
Use as a battery charger
Check the electrolyte level
in all the elements of the
battery.
CHARGE
PERCENTAGE
100%
75%
50%
25%
GE 2500 SR FAMILY
GE 3200 H FAMILY
GE 4500 HBS
3. Connect the positive (Red) re-charge cable to the
positive pole of the battery (Pos +).
4. Go away as far as possible from the battery with
the final free cable, then connect the negative
(Black) to the terminal of the free cable.
5. Do not stay in front of the battery when making
the final connection.
6. Connect the re-charge cables in the appropriate
place of the generator.
7. Start the engine.
8. When disconnecting the re-charge cables, opera-
te always in the opposite sequence of the connec-
ting procedure and eliminate the first connection
staying at a fairly reasonable distance from the
battery.
SUGGESTION FOR THE USE
The terminal in C.C. can be used to charge 12V car
type batteries only.
!
CAUTION
• It is dangerous to work near a lead battery.
• The batteries produce explosive gas; sparks,
flames, cigarettes, are to be kept far from them.
Make sure that when they are being recharged
there is adequate ventilation around the battery.
• It is not allowed to supply a low voltage electric
system.
• It is not allowed to charge dry batteries.
To reduce the risk of battery explosions follow the
following instructions and those appearing on the
label applied onto the battery.
The battery contains sulphuric acid (electrolyte).
The contact with eyes and skin may cause se-
vere lesions. Wear protective garments and eye
protections.
• If the electrolyte comes in contact with the
skin,wash with plenty of water.
• If the electrolyte comes in contact with the
skin,wash with plenty of water.If it comes in
contact with the eyes wash with fluent water
for at least 15 minutes and rush for a doctor.
The electrolyte is poisonous.
• if swallowed drink plenty of water or milk, then
milk of magnesia or vegetable oil and call for a
doctor.
Keep away from children.
M
36