Machine Description; Operation Capabilities; Conventions; Description - Nilfisk BR 601 Manuel D'utilisation

MACHINE DESCRIPTION

OPERATION CAPABILITIES

This scrubber-dryer is used to clean (scrubbing and drying)
smooth and solid floors, in civil or industrial environment,
under safe operation conditions by a qualified operator.
The scrubber-dryer cannot be used for fitted carpet and
carpet cleaning.

CONVENTIONS

Forward, backward, front, rear, left or right are intended with
reference to the operator's position, that is to say on the
driver's seat (25, Fig. C).

DESCRIPTION

Control panel
(See Fig. B)
1. Control panel
2. Emergency stop button
3. Horn
4. Brush/pad-holder deck and squeegee lifting/lowering
switch
5. Brush/pad-holder extra pressure switch (disabled when
the cylindrical brush deck is installed)
6. Squeegee lifting/lowering and vacuum ON/OFF switch
7. Battery charge indicator
7a. Green warning light (ON: charged batteries)
7b. Yellow warning light (ON: nearly discharged batteries)
7c. Red warning light (ON: discharged batteries)
8. Hour counter and solution or washing water level
display:
– When the machine is started, it displays for a few
seconds the number of working hours which have
been performed.
– While using the machine, it displays the solution or
washing water level in the tank (measured in
percentage terms, compared with the full tank).
When the level is below 20%, the display starts
blinking.
The display could indicate "000 %" even if the tank is
not completely empty, thus allowing to complete the
cleaning cycle; in any case, it is recommended to
check the actual washing water flow supplied to the
brushes.
9. Detergent flow control switch (optional)
10. Washing water control switches
10a. Flow increase switch
10b. Flow decrease switch
11. Maximum speed adjuster (enabled only when the
brushes are operating)
12. Ignition key
909 6160 000(2)2006-10 A
Outside view
(See Fig. C)
1. Steering wheel inclination control lever
2. Steering wheel
3. Forward/reverse gear pedal
4. Brush/pad-holder deck
5. Cylindrical brush deck
6. Side skirts
7. Battery charger cable housing
8. Cable with battery charger plug (optional)
9. Filter for:
– Solution
– Washing water (optional)
10. Recovery water drain hose
11. Squeegee vacuum hose
12. Squeegee
13. Bumper wheels
14. Squeegee support wheels
15. Squeegee mounting handwheels
16. Squeegee balance adjusting knob
17. Front squeegee blade
18. Rear squeegee blade
19. Squeegee rear blade fastening hook
20. Solution or washing water tank (according to the system
equipped)
21. Recovery water tank
22. Recovery water tank cover
23. Flashing light (optional)
24. Solution or washing water drain tap (according to the
system equipped)
25. Seat
26. Battery charger (optional)
27. Electromagnetic brake
28. Front steering, driving and braking wheel
29. Electromagnetic brake unlock screws
30. Serial number plate/technical data/EC certification
31. Rear wheels
USER MANUAL
5