Inspection And Maintenance; Maintenance Schedule - Suzuki DF4 Manuel Du Propriétaire

INSPECTION AND MAINTENANCE

NOTICE
MAINTENANCE,
REPAIR OF
DEVICES AND SYSTEMS MAY BE PER-
FORMED BY ANY MARINE SI ENGINE
REPAIR ESTABLISHMENT OR INDIVIDUAL
USING ANY PART WHICH HAS BEEN
CERTIFIED UNDER THE PROVISIONS IN
THE CLEAN AIR ACT Sec. 207 (a) (2).

MAINTENANCE SCHEDULE

It is important to inspect and maintain your out-
board motor regularly. Follow the chart below.
Interval
Item to be serviced
Spark plug
Breather & Fuel line
Engine oil
Gear oil
Lubrication
Anodes
* Engine oil filter
* Fuel filter
* Ignition timing
* Carburetor
* Idle speed
* Valve clearance
* Water pump
* Water pump impeller
* Propeller nut & pin
* Bolts & Nuts
I: Inspect and clean, adjust, lubricate, or replace, if necessary T: Tighten R: Replace
36
REPLACEMENT
EMISSION CONTROL
Initial 20 hrs.
or 1 month
–
I
R
R
–
–
–
–
–
I
I
I
–
–
I
T
At each interval, be sure to perform the indi-
cated service. Maintenance intervals should be
OR
judged by number of hours or number of
months, whichever comes first.
Exhaust gas contains carbon monoxide,
a dangerous gas that is difficult to detect
because it is colorless and odorless.
Breathing carbon monoxide can cause
death or severe injury.
Never start the engine or let it run indoors
or where there is little or no ventilation.
Every 50 hrs.
or 3 months
–
I
–
–
I
I
–
I
Replace every 400 hours or 2 years.
–
–
–
–
–
–
–
–
 WARNING
Every 100 hrs. Every 200 hrs.
or 6 months or 12 months
I
I
R
R
I
I
–
I
–
I
–
–
–
–
I
T
R
I
R
R
I
I
I
I
I
I
I
I
I
R
I
T