Care And Maintenance; Cleaning The Balance; Disposal; Specifications - Sartorius Secura Notice D'installation Et D'utilisation

Care and Maintenance

Service
To ensure the continued accuracy of your balance, we recommend
scheduling regular servicing at least once a year. Sartorius Service
offers different service contracts with maintenance intervals that are
tailored to your needs. A calibration certificate should be issued as
part of every maintenance session. Safety inspections of the AC
adaptor and its connections must be performed at appropriate
intervals by a qualified electrician (e.g. every 2 years).
Repairs
Repair work must only be carried out by trained
service technicians. Repairs performed by untrained
persons will invalidate the warranty, and may result in
consider able hazards for the user and cause the bal-
ance to produce inaccurate results. Contact Sartorius
Service or a Sartorius dealer for proper repair of your
balance. The device must be unplugged during repair
work. Unplug the power cord. Repair work must only
be performed by Sartorius-trained service technicians.

Cleaning the Balance

Cleaning the Control Panel
Switch the display to Standby mode to avoid modifying the settings
for operation during cleaning.
t
Touch the "Menu" key to switch to application
selection.
t If you then touch E, the display goes off.
t
To switch the display back on again:
Select j at the bottom left of the display.
Cleaning the Balance Housing
Disconnect from the power supply:
Unplug the AC adaptor from the mains. If necessary,
disconnect the data cable connected to the balance.
Never open the balance or the AC adaptor.
The parts contained in these cannot be cleaned,
repaired, or replaced by the operator.
– The parts contained in these cannot be cleaned, repaired,
or replaced by the operator.
– Remove the base plate, pan support, and weighing pan from the
wind shield.
– Never use cleaning agents that contain solvents or abrasive
ingredients, which can ultimately damage the equipment.
Secura and Quintix-Models:
t
The plastic top and bottom parts of the balance housing are
coated with a special substance that allows these parts to be
cleaned using acetone.
Do not clean the following parts with acetone or
aggressive cleaning agents: control panel, mains
plug, data interface, labels, verified seal, or any other
plastic parts.
t
Wipe the balance with a soft, dry cloth after cleaning.
Contaminated equipment:
– Health risk posed by product contamination due
to product deposits and collection of residue with
microbial contamination.
– Health risk posed by biological and
microbiological substances.
– Observe cleaning specifications.
– Examine the cleaning results closely.
8
Installation and Operating Instructions Secura, Quintix, Practum
A) Remove the side panels:
1) Gently lift the side panels at the rear
and pull them back and out.
B) Remove the top glass cover:
1) Holding it by its rear edge, pull the
draft shield cover up and remove the
draft shield cover.
2) Remove the top glass cover by pulling
it backward.
3) Then replace the draft shield cover. In
doing so, the draft shield cover must
lock into position.
After cleaning put together the components in reverse order:
see Chapter "Getting Started – Installing the Balance," page 5.
C) Remove the front and rear glass:
Detailed information about the assembly steps can be found in
the User Manual, which can be downloaded online.
Go to www.sartorius.com – "Service Center Downloads".

Disposal

The packaging is made from environmentally-
friendly materials that can be used as secondary
raw materials. If you no longer need this packaging,
bring it to your local recycling and waste disposal
facility according to the regulations applicable in
your country. In Germany, you can dispose of this
material using the VfW dual system (contract
number D-59101-2009-1129). The equipment,
including accessories and batteries, must not be
disposed of in general household waste, and must be recycled
similar to electrical and electronic devices. For further information
about disposal and recycling options, please contact your local
service staff. The partners listed on the following website can be
used for disposals within the EU:
1) Go to http://www.sartorius.com.
2) Select the summary under "Service."
3) Then select "Information on Disposal."
4) Addresses for local Sartorius disposal contacts can be found in
the PDF files given on this webpage.
h
Sartorius will not take back equipment contaminated with
hazardous materials (ABC contamination) either for repair
or disposal.
Insert heading: "Service Address for Disposal"
Please refer to our website (www.sartorius.com) or contact the
Sartorius Service Department for more detailed information
regarding repair service addresses or the disposal of your device.