optrel e3000 Mode D'emploi page 9

Alarm function
Filter clogging alarm: When the filter clogging alarm is tripped, the LED shows
red. To replace the prefilter and main filter, press and hold the On/Off button for 2
seconds to turn off the e3000. You can now change the filters. If you do not turn
off the e3000 while an alarm exists, it will continue to run for 15 minutes before
switching off automatically�
Battery alarm: When the battery alarm is tripped, the LED shows red. A beep is
emitted every second; you can continue using the device for approx. 30 minutes.
The e3000 then switches itself off�
Storage
The e3000 system and accessories must be stored in a dry place. Protect it against
sunlight, high temperatures, hydrocarbons and solvent vapours.
Maintenance
Check the helmet regularly according to the operating instructions. Check the face
seal and the air nozzle for holes, cracks or other damage and make sure that the
parts are correctly positioned on the helmet (see instruction manual). Do not use
the system until all worn or damaged parts have been replaced.
Maintenance schedule
Activity
Cleaning, disinfection
Visual inspection
Charging the battery
Replace seal between main filter and blower unit
When the device is in storage, the battery must be recharged every 4 months.
Cleaning and disinfection
Clean the blower, air hose and helmet using a cloth moistened with soapy water.
Allow the unit to dry at room temperature. Do not use aggressive cleaning agents
or solvents, alcohol or abrasive cleaning agents. The mechanical seal is washable
(hand wash, do not spin).
Troubleshooting
Blower does not switch on
→ Make sure the battery is inserted correctly.
→ Make sure the battery is fully charged.
Filter alarm is activated even though the pre- and main filters have been
replaced and are correctly installed
→ Internal e3000 error
→ Return the e3000 system to the nearest dealer.
Battery life is too short
→ Battery defective – Replace battery and dispose of defective battery as
hazardous waste�
→ Charger defective - replace.
Technical data
(We reserve the right to make technical changes�)
Nominal protection factor Europe: TH3P/TH2P classification (see page IV)
Australia: P3 classification
Blower unit
Air flow rates:
Material
Polyamide (PA-GF)
Blower
High-quality, ball-bearing mounted blower motor
Fuse
Electronic fuse
Frequency
Always after use
Always before and after use
After each use
Replace only if the seal is worn or damaged
Level 1: min. 150 Nl/min*
Level 2: min. 200 Nl/min*
Level 3: min. 250 Nl/min*
*In standard conditions:
20 °C, 0 meters above sea level.
Sea level (1013 hPa)
All levels controlled
Battery Type
Type:
Voltage / capacity:
Charging cycles:
Operating time level 1*
Operating time level 2*
Operating time level 3*
Charging time:
Weight:
Colour:
*min. operating time is with new filter at room temperature
Noise level
Max. 70 dB(A)
Warning signals Audible and visual alarm for low battery, clogged or missing filter
and low airflow
Filter 1x type TH3P R SL
for TH3P system (Europe)/TH3P system (Australia)
Air hose Length:
Diameter:
Weight:
Colour:
Weight
1195g / 42.152 oz (incl. filter and belt, without battery)
Dimensions
LxWxH: 222 x 213 x 92.6 mm
Standards
EN 12941:1998 /A2:2008, EAC TP TC 019/2011, AS/NZS 1716
Notified body CE 1024
SAI Global
Scope of delivery/Spare parts (see page I, II, lll)
1 e3000 PAPR
2 Main filters TH3P R SL filter for TH3P system (Europe)/TH3P system (Australia)
3 Prefilter
4 Spark arrester
5 Filter cover
6a Standard battery (Lithium-Ion 37 Wh)
6b Long life battery (Lithium-Ion 74 Wh)
7 PAPR-compatible safety helmet
9 Hose
10 Protective cover for air hose (accessories, not included)
Further accessories can be found in the main catalogue or on our website�
Explanation of symbols (see page IV)
A Read operating instructions before use
B Do not open with sharp objects
C Fragile content
D Store with this side facing up
E Protect from moisture
F Notified body identification mark
G Mark of conformity EAC (Russia)
H Contains lithium ions
I Plastic, recyclable
J Recommended storage temperature: 5 C° to +25 C°
K Do not dispose of as domestic waste. Dispose of as hazardous waste.
Declaration of Conformity
See the Internet address on the last page.
Legal information
This document complies with the requirements of EU Regulation 2016/425
section 1.4 of Annex II.
Notified body
For detailed information see last page.
9
Standard Long Life
Li-Ion rechargeable Li-Ion rechargeable
14.8V / 2.5Ah 14.8V / 5.0Ah
> 500 > 500
12 h 20 h
10 h 18 h
8 h 14 h
approx. 5h approx. 8h
420g / 14.815 oz 565g / 19.930 oz
black black
1160 mm (elastic upto 1300mm with
protective sleeve)
31 mm (inside)
185g / 6.526 oz (without protective cover)
black