Overview And Use; System Safety; Closing Valve For Water Supply; Closing Valve For Air Supply - Ecolab Hybrid Foamatic MA2CM Mode D'emploi

4. Overview and use

The satellite in the hybrid range is a completely func-
tioning hygiene station that supplies pre pressurised
water to both its integrated hygiene points (optional)
and to several connected cleaning areas. Therefore
the satellite must be supplied with:
Pressurised water in sufficient quantity, power, com-
pressed air, detergent(s) and disinfectant.
The satellite is then ready for hygiene duties.
Warning: Do not use the water from
the system for applications other than
cleaning.
Consumptions:
The unit is approved for the use of detergents and
disinfectants.
Warning: Do not change the settings
made or recommended by the supplier
of the detergents!
Detergents are supplied via a User Pack system or
from separate standard cans. Supply is also possible
via piping systems.
Before installation and set up of the unit always read
this instruction thoroughly. Always make sure to
follow personal safety procedures for chemicals in
connection with refilling procedures (product change),
maintenance and repair. maintenance and repair. See
also product label and Material Safety Data Sheet
(MSDS).
Warning: Be aware that mixing of
chemicals during use can lead to a
dangerous chemical reaction potentially
dangerous to the user.
Safety instructions
Only professional service personel are allowed to
carry out service and repairs on the unit.
Only instructed personel are allowed to operate the
unit.

5. System safety

In case of error/defect or service on equipment:
1. Close the water supply
2. Close the air supply
3. Turn of power supply
Open
184

5.1. Closing valve for water supply.

With this valve the unit can be isolated from the water
supply. Further, a non-return valve is built in the block
to prevent backflow of water.
Closed

5.2. Closing valve for air supply.

With this valve the unit can be isolated from the air
supply. Two non-return valves for air are built in the
unit to prevent backflow of air.

5.3. Noise

Sound level according to ISO 11202; Below 70 dB

5.4. Vibrations

Hand-arm vibrations according to ISO 5349-1
Closed
Open
110005287
The air pressure regulation/gauge only
works when the supply valve is open.
Wear glasses when using the unit.
Wear gloves and suitable clothing
when using the unit.
Warning: The spray jets can be dan-
gerous if subjected to misuse. The jets
must not be directed at persons, live
electrical equipment or the unit itself.
Warning: Do not use the unit within
range of persons unless they wear
protective clothing.