Diesel Air Filter; Fuel; Fuel System - Jacobsen Greens King V Plus Manuel De Maintenance

4 MAINTENANCE
GB
4.4

DIESEL AIR FILTER

Check the service indicator daily. If red band
appears in the window (C) replace the element.
Do not remove the element for inspection or
cleaning. Unnecessary removal of the filter
increases the risk of injecting dust and other
impurities into the engine.
When service is required, first clean the outside of
the filter housing; then remove the old element as
gently as possible and discard.
1. Carefully clean the inside of the filter
housing without allowing dust into the air
intake.
2. Inspect the new element. Do not use a
damaged element and never use an
incorrect element.
4.5

FUEL

Handle fuel with care - it is highly flammable.
Use an approved container, the spout must fit
inside the fuel filler neck. Avoid using cans and
funnels to transfer fuel.
WARNING
Never remove the fuel cap from the fuel
tank, or add fuel, when the engine is
running or while the engine is hot.
Do not smoke when handling fuel. Never
fill or drain the fuel tank indoors.
Do not spill fuel and clean spilled fuel
immediately.
Never handle or store fuel containers
near an open flame or any device that
may create sparks and ignite the fuel
or fuel vapors.
Be sure to reinstall and tighten fuel cap
securely.
4.6

FUEL SYSTEM

Refer to Section 6.3 for specific maintenance
intervals.
Before replacing any filter, thoroughly clean the
filter housing and the area around the filter. Dirt
JACOBSEN GREENS KING V PLUS
MAINTENANCE AND PARTS MANUAL
3. Assemble the new element and make sure
it seats properly. Reset the indicator by
depressing button (D).
4. Reassemble cap making sure it seals
completely around the filter housing. Dust
evacuator must be facing down.
5. Check all hoses and air ducts. Tighten
hose clamps.
• Fill the fuel tank to within 1 in. (25 mm)
of the bottom of the filler neck.
• Store fuel according to local, state or
federal ordinances and recommendations
from your fuel supplier.
• Never overfill or allow the tank to
become empty.
• Check fuel lines and clamps every 50
hours. Replace fuel lines and clamps at
the first sign of damage.
• Use clean, fresh, #2 Diesel fuel.
Minimum Cetane rating 45. Refer to
Engine Manual for additional information.
must not be allowed to enter into fuel system.
For diesel engines, turn the key switch to the ON
position to start the fuel pump, and bleed the fuel
system after the fuel filter and lines have been
removed, or the fuel tank has become empty. See
Engine Manual.
GB-15