Operation; Determine Type Of Solution Needed; Manitowoc Ice Machine Cleaner; Manitowoc Ice Machine Sanitizer - Manitowoc AuCS S Serie Manuel D'installation, D'utilisation Et D'entretien

Determine Type of Solution Needed

! Caution
Use only Manitowoc approved Ice Machine
Cleaner & Sanitizer. It is a violation of Federal law
to use these solutions in a manner inconsistent
with their labeling. Read and understand all labels
on the bottles before use.
The AuCS® accessory will dispense Cleaner OR
Sanitizer. It cannot dispense both at the same time.

MANITOWOC ICE MACHINE CLEANER

Part Number 94-0546-3 (AuCS®-SO)
Part Number 40-1326-3 (AuCS®-SI)
Ice Machine Cleaner is used to control build-up and to
remove lime scale or other mineral deposits. It will not
"sanitize" the ice machine.
It is recommended for use in places that have lime scale
or other mineral deposits, but no problems with slime.
Model Amount of Cleaner Dispensed
22" or 30"
Ice Machine
48" Ice Machine

MANITOWOC ICE MACHINE SANITIZER

Part Number 94-0565-3 (AuCS®-SO)
Part Number 40-1327-3 (AuCS®-SI)
Ice Machine Sanitizer is used for sanitizing and
controlling algae build-up (slime) and other bacterial
growth. The ice machine (and bin or dispenser) must be
sanitized on a regular schedule, following Manitowoc
recommendations and local regulations.
It is recommended for use in places such as pizzerias,
bars, bakeries, etc., that have airborne bacteria (yeast).
Sanitizing is also recommended in places that do not
have lime scale (or other mineral deposit problems).
Model Amount of Sanitizer Dispensed
22" or 30"
Ice Machine
48" Ice Machine
10
Section 3

Operation

3 oz (88 ml)
6 oz (177 ml)
3 oz (88 ml)
6 oz (176 ml)

Hose Priming

The dispenser pump requires priming after initial
installation, or if the hose between the AuCS®-SI
reservoir and pump has been pumped dry or the tubing
between the AuCS®-SO pump and the ice machine has
been pumped dry.
!
Do not blow into or suck on the hose in an attempt
to prime it.
Perform the following procedure:
1. Move the ice machine toggle switch to CLEAN.
2. The water pump and dump valve will turn on. The
dump valve will shut off after approximately
45 seconds.
3. The control waits until water contacts the water level
probe then energizes the AuCS® pump (22" or 30"
ice machines - 30 seconds, 48" ice machines -
60 seconds).
4. Allow the ice machine to complete the cleaning or
sanitizing cycle. Refer to "Manual Start Operation"
for details.
Important
The priming procedure starts the automatic cleaning
mode. Upon moving the ice machine toggle switch
to ICE, the ice machine will run through 6 rinse and
dump cycles before making ice.
Warning
Part Number 000007647 06/11