Operation; Determine Type Of Solution Needed; Manitowoc Ice Machine Cleaner; Manitowoc Ice Machine Sanitizer - Manitowoc iAuCS Manuel D'installation, D'utilisation Et D'entretien

Determine Type of Solution Needed

! Caution
Use only Manitowoc approved Ice Machine
Cleaner & Sanitizer. It is a violation of Federal law
to use these solutions in a manner inconsistent
with their labeling. Read and understand all labels
on the bottles before use.
The AuCS® accessory will dispense Cleaner OR
Sanitizer. It cannot dispense both at the same time.

MANITOWOC ICE MACHINE CLEANER

Part Number 94-0546-3
Ice Machine Cleaner is used to control build-up and to
remove lime scale or other mineral deposits. It will not
"sanitize" the ice machine.
It is recommended for use in places that have lime scale
or other mineral deposits, but no problems with slime.
Model Amount of Cleaner Dispensed
22" or 30"
Ice Machine
48" Ice Machine

MANITOWOC ICE MACHINE SANITIZER

Part Number 94-0565-3
Ice Machine Sanitizer is used for sanitizing and
controlling algae build-up (slime) and other bacterial
growth. The ice machine (and bin or dispenser) must be
sanitized on a regular schedule, following Manitowoc
recommendations and local regulations.
It is recommended for use in places such as pizzerias,
bars, bakeries, etc., that have airborne bacteria (yeast).
Sanitizing is also recommended in places that do not
have lime scale (or other mineral deposit problems).
Model Amount of Sanitizer Dispensed
22" or 30"
Ice Machine
48" Ice Machine
Part Number 000009036 8/13
Section 3

Operation

3 oz (88 ml)
6 oz (177 ml)
3 oz (88 ml)
6 oz (176 ml)

Hose Priming

The dispenser pump requires priming after initial
installation, or if the hose between the AuCS® reservoir
and pump has been pumped dry or the tubing between
the AuCS® pump and the ice machine has been
pumped dry.
!
Do not blow into or suck on the hose in an attempt
to prime it.
Perform the following procedure:
1. Press the CLEAN button.
2. The water pump and dump valve will turn on. The
dump valve will shut off after approximately
45 seconds.
3. The control waits until water contacts the water level
probe then energizes the AuCS® pump (22" or 30"
ice machines - 30 seconds, 48" ice machines -
60 seconds).
4. Allow the ice machine to complete the cleaning or
sanitizing cycle. Refer to "Manual Start Operation"
for details.
Important
The priming procedure starts the automatic cleaning
mode. After starting an ice making cycle, the ice
machine will run through 6 rinse and dump cycles
before making ice.
Warning
11