ZF Marine ZF 220 A Manuel D'utilisation page 5

Operating manual ZF 220 A - ZF 220 V - ZF 220 IV - IRM 225 A - ZF W 220
V TROUBLE SHOOTING (reference Fig. 11-12)
Problem
1. Low oil pressure
2. Slow engagement
3. Clutch does not disengage
4. Clutch does not engage
5. High oil temperature
6. Vibration through speed range
7. Oil leaks
VI WARRANTY
Standard Warranty
ZF-HURTH MARINE warrants its type ZF - IRM Reversing
Marine Transmission to be free from defects in material and
work-manship under normal use and maintenance, provided
that this warranty shall apply if, and only if, the equipment
has been properly installed and operated.
The obligation of ZF-HURTH MARINE under this warranty
shall be limited to the replacement or repair, at its choice,
of any part or parts found to be defective by ZF-HURTH
MARINE upon its examination of same, provided that the
part or parts are returned to the nearest official ZF-HURTH
MARINE distributor, freight prepaid, within the time:
twenty-four (24) months from date of commissioning or
thirty-six (36) months from date of delivery to engine manu-
facturer, whichever occurs first.
The obligations of ZF-HURTH MARINE under this warranty
as set forth herein shall also be subject to compliance by
the distributor or engine manufacturer who has purchased
the product with the Warranty Procedures which is made a
part of this warranty. All warranties shall run to distributors
and engine manufacturers who have purchased the type
ZF - IRM Reversing Marine Transmission.
Cause
Dirty filter (Pos. 2)
Pipe filter and/or heat exch. (Pos. 9)
obstructed
Wrong oil type
Broken pump (Pos. 4)
Leaky gaskets or seals
Broken clutch
Filter (Pos.2) obstructed
Leaks from cooler lines or cooler
Wrong oil type
Low oil pressure
Burnt clutch
Low oil pressure
Wrong oil type
Pipe, filter and/or heat
exchanger (Pos. 9)
Broken coupling
Screws securing to the hull loose
Misalignment to propeller shaft
Propeller broken
Oil seal broken
Pipes broken
Heat exchanger (Pos. 9) damaged
Remedy
Clean filter
Check and clean
Use recommended oil
Check and replace
Contact After Sales Service
Contact After Sales Service
Clean filter
Check and replace
Use recommended oil
Operate as at first point
Contact After Sales Service
Operate as at first point
Use recommended oil
Check and replace
Contact After Sales Service
Check and tighten if required
Check and contact After Sales
Replace
Check and contact After Sales Service
Check and replace
Check and replace
This warranty shall not apply to any part or parts which
have been repaired or altered, without the prior written
consent of an official ZF-HURTH MARINE dealer.
This warranty shall not apply if the product or any of its
components or parts have been subject to misuse, abuse,
negligence, alteration, or accident, or have not been
operated in accordance with printed instructions of ZF-
HURTH MARINE or has been operated under conditions
more severe than, or otherwise exceeding, those set forth
in the specifications for said product, or has been improperly
installed or reinstalled, or improperly maintained and
operated.
This warranty is expressly in lieu of all other warranties
expresses or implied including the warranties of
merchantability and fitness for use and of all other
obligations including without limitation, consequential
damages, and ZF-HURTH MARINE neither assumes nor
authorizes any other person to assume for ZF-HURTH
MARINE, any other liability in connection with the sale of
the ZF - IRM REVERSING MARINE TRANSMISSION.
ZF-HURTH MARINE shall in no event be liable for any breach
of warranty in an amount exceeding the purchase price of
the ZF - IRM REVERSING MARINE TRANSMISSION.
5