Martin Yale papermonster F100 Instructions D'opération page 5

GB
UNJAMMING INSTRUCTIONS
1. If paper becomes jammed, unplug the fold-
er.
2. From the bottom of the folder, remove the pa-
per stop (see Figure 1) by gently flexing it in
the middle and with drawing one end first.
3. Also remove the dejamming handle by turn-
ing it in either direction while pulling gently.
4. Insert the dejamming handle through the hole
in the folder cover onto the D-shaped shaft
inside the unit (see Figure 4).
Housing
„D" shaft
Hole plug
Figure 4
5. Turn the han-dle in either direction while care-
fully pulling the paper out the top or bottom of
the folder.
If unable to clear the jam, see the DISAS-
SEMBLY INSTRUCTIONS below.
After the jam has been cleared, return the
dejamming handle and paper stop to their
normal positions. Plug in the folder.
DISASSEMBLY INSTRUCTIONS
Use this procedure to clear a difficult paper jam
or to clean the folding rollers.
1. Unplug the folder.
2. Remove the four screws from the bottom of
the folder and lift off cover. Return the folder
to its normal upright position.
3. To clear a paper jam, remove the plastic pa-
per stop from the bottom of the folder (see
Figure 1). Turn the large pulley on the left side
in either direction while carefully pulling the
paper from the top or bottom of the folder.
DESKTOP FOLDER
4. To clean the rubber rollers, spray Martin Yale
Roller Cleaner on a clean, lint-free cloth and
rub the rollers to wipe them clean. Rotate the
rollers by turning the large pulley in either di-
rection.
Repeat the process until the rubber and steel
rollers are clean and completely dry.
Note:
Use of a cleaner other than Martin
Yale Roller Cleaner could damage
the rollers.
Infrared transmitter
blue
yellow
blue
24 V.D.C.
black
MALFUNCTION
DISPOSING OF THE MACHINE:
Dispose of the machine in an envi-
ronmentally sound fashion at the
end of its usefull service life. Do not
dispose of any of the parts included
in the machine or its packing with
household trash.
SPECIAL ACCESSOIRES
Description
Martin Yale Roller Cleaner
Note: For orders of special accessoires and spare parts, please contact your dealer.
Operation: Manual feed, automatic on/off,1800 letter folds per hour
Paper Sizes: Adjustable for 2 standard paper sizes; 8 1/2" x 11" to fit a #10 enve-
lope and ISO A4 paper (210 x 297 mm)
Capacity: 1–3 sheets of 16-–24# bond paper.
Sheets may be stapled.
Power:
1,2 Amp 24 Volt wall pack power supply
Size: 12 3/4" W x 6" H x 5 1/1" D (326 mm W x 153 mm H x 140 mm D)
Weight: 7.5 lbs. (3.4 kg)
5
TROUBLESHOOTING
If the folder does not function and no paper jam
is present, the circuit breaker may have tripped.
Reset by unplugging the folder for at least
1 minute to allow circuit breaker to cool. Paper
folder should then function again.
Don't forget to check that the folder is plugged
into a working AC outlet.
Inconsistent or otherwise problematic folding is
most often caused by dirty or contaminated fold-
ing rollers. Clean rollers as outlined in section
DISASSEMBLY INSTRUCTIONS.
Infrared receicer
red black
Circuit board
red
black
TECHNICAL DATA
F100
WIRING SCHEMATIC
24 V.D.C. Motor
Order-No.
99977