Table des Matières
Publicité
Liens rapides
A.O. Smith - Voltex™
Hybrid Electric
Heat Pump Water Heater
Installation
Instructions and
Use & Care Guide
To obtain technical, warranty or service assistance during or after
the installation of this water heater, call toll free
1-800-527-1953
When calling for assistance, please have the following
information ready:
1. Model number
2. 7 Digit product number
3. Serial number
4. Date of installation
5. Place of Purchase
Table of Contents
Water Heater Safety ............................................................................... 2
Installing Your Water Heater ................................................................. 3-9
Installation Checklist .............................................................................. 10
Operating Your Water Heater ........................................................... 11-13
Maintenance of Your Water Heater .................................................. 14-15
Diagnostic Codes .................................................................................. 16
Troubleshooting Chart ........................................................................... 17
Repair Parts Illustration ......................................................................... 18
Notes... .............................................................................................. 19-20
All manuals and user guides at all-guides.com
Consumer Information ................................................................ 3
Consumer Responsibilities ......................................................... 3
Unpacking Instructions ............................................................ 3-4
Location Requirements ............................................................... 4
Water System Piping ................................................................ 5-6
Temperature & Pressure Relief Valve ....................................... 7-8
Electrical Requirements ........................................................... 8-9
Before Using ............................................................................. 11
Water Temperature Regulation ................................................. 11
Adjusting the User Interface Module/ Operational Mode .......... 12
Operational Conditions ............................................................. 13
Temperature and Pressure Relief Valve .................................... 14
Draining and Flushing ................................................................ 14
Heating Element Replacement ............................................. 14-15
Cleaning the Heat Pump ........................................................... 15
Page
320506-000
November 2010
1
Publicité
Table des Matières
Manuels Connexes pour AO Smith Voltex
Sommaire des Matières pour AO Smith Voltex
-
Page 1: Table Des Matières
All manuals and user guides at all-guides.com A.O. Smith – Voltex™ Hybrid Electric Heat Pump Water Heater Installation Instructions and Use & Care Guide To obtain technical, warranty or service assistance during or after the installation of this water heater, call toll free... -
Page 2: Water Heater Safety
All manuals and user guides at all-guides.com WATER HEATER SAFETY Your safety and the safety of others are very important. We have provided many important safety messages in this manual and on your appliance. Always read and obey all safety messages. This is the safety alert symbol. -
Page 3: Installing Your Water Heater
All manuals and user guides at all-guides.com INSTALLING YOUR WATER HEATER Consumer Information elements, the more effi cient the unit will be. The tank capacity of this heat pump water heater is sized to This water heater should be installed in accordance with maximize the use of the heat pump to deliver hot water at the local code authority having jurisdiction, the power a lower cost as compared to heat pump waters with lower... -
Page 4: Location Requirements
All manuals and user guides at all-guides.com • Inspect all parts for damage prior to installation and IMPORTANT: The water heater should be located in an start-up. area where leakage of the tank, connections, condensate • Completely read all instructions before attempting to lines or condensate will not result in damage to the area adjacent to the water heater or to lower floors of the assemble and install this product. -
Page 5: Water System Piping
All manuals and user guides at all-guides.com Water System Piping 3. Some local codes may require, and the manufacturer of this water heater recommends, installing a mixing Piping, fi ttings, and valves should be installed according to valve or an anti-scald device in the domestic hot water the installation drawing (Figure 4). -
Page 6: Explosion Hazard
All manuals and user guides at all-guides.com Closed System/Thermal Expansion Please note the following: • The system should be installed only with piping that is suitable for potable (drinkable) water such as copper, CPVC, or polybutylene. This water heater must not be installed using iron piping or PVC water piping. -
Page 7: Temperature & Pressure Relief Valve
All manuals and user guides at all-guides.com Temperature and Pressure exceed the marked maximum working pressure of the water heater. Install the valve into an opening provided and Relief Valve marked for this purpose in the water heater, and orient it or provide tubing so that any discharge from the valve exits only within 6 in. -
Page 8: Electrical Requirements
All manuals and user guides at all-guides.com When making the electrical connections, always make sure: Figure 6 • The electrical service provides 240 VAC to the water heater T&P Relief Valve Insulation for proper operation. DO NOT use 208 VAC. •... -
Page 9: Insulation Blankets
All manuals and user guides at all-guides.com 5. Connect these two wires to the two wires on the water Figure 8A heater using wire nuts or other connectors. Junction Box 6. Connect the free ends of the two wires to the shut off Green switch on the condensate pump in accordance with the Ground... -
Page 10: Installation Checklist
All manuals and user guides at all-guides.com INSTALLATION CHECKLIST Water Heater Location Regulation” section). Condensate Drain Line Installation □ Centrally located with the water piping system. □ The fl ooring beneath the water heater must be able to □ Must be located with access to an adequate drain or support the weight of the water heater when fi... -
Page 11: Operating Your Water Heater
All manuals and user guides at all-guides.com OPERATING YOUR WATER HEATER Water Temperature Regulation Before Using 1. Make sure the water heater has been properly WARNING installed. See “Installing Your Water Heater” section. 2. Make sure the air filter is correctly seated, as it may shift during shipping or installation. -
Page 12: Adjusting The User Interface Module/ Operational Mode
All manuals and user guides at all-guides.com Adjusting the User Interface Module/Operational Modes Water Temperature Adjustment Other Controls The water temperature can be adjusted from 95°F (35°C) Lock - Holding this button for more than 3 (95°F) to 150F° (65.5°C). Use the Up and Down Buttons seconds switches the lock mode on or off. -
Page 13: Operational Conditions
All manuals and user guides at all-guides.com Operational Conditions Water Heater Sounds During the normal operation of the water heater, sounds or Powered Anode Operation noises may be heard. These noises are common and may result from the following: To shelter the glass-lined water tank from corrosion through electrolysis, this water heater is equipped with a 1. -
Page 14: Maintenance Of Your Water Heater
All manuals and user guides at all-guides.com MAINTENANCE OF YOUR WATER HEATER Temperature and Pressure 5. Connect a hose to the drain valve and terminate it to an adequate drain or external to the building. Relief Valve 6. Open the water heater drain valve and allow all of the water to drain from the tank. -
Page 15: Cleaning The Heat Pump
All manuals and user guides at all-guides.com Routine Preventive Maintenance Figure 12: At least monthly, a visual inspection should be made of the following: Wires • Air Filter (Remove and inspect, clean if needed, and reinstall). • Condensate drain pan and condensate lines. Element •... -
Page 16: Diagnostic Codes
All manuals and user guides at all-guides.com DIAGNOSTIC CODES DISPLAY SHOWS INDICATES CORRECTIVE ACTION UPPER ELEMENT Upper element is not Turn off power at the circuit breaker/fuse box and check for functioning a loose connection at the element. For access directions CONNECT see “Heating Element Replacement”... -
Page 17: Troubleshooting Chart
All manuals and user guides at all-guides.com DIAGNOSTIC CODES ELECTRONIC Indicates the power anode is Contact a qualified person to service the unit. not operating properly POWER ANODE ERROR #0-9 (# CAN BE 0-9) NOTE: The diagnostic codes listed above are the most common. If a diagnostic code not listed above is displayed, contact Residential Technical Assistance referencing the number on the front of this manual. -
Page 18: Repair Parts Illustration
All manuals and user guides at all-guides.com REPAIR PART ILLUSTRATION REPAIR PARTS LIST PARTS DESCRIPTION ITEM Upper Access Cover Lower Access Cover Upper Element (4500 Watts) Lower Element (2000 Watts) Energy Cut-Off (ECO) Switch Temperature & Pressure Relief Valve (T&P) Dip Tube (at hot water outlet) Powered Anode Rod User Interface Module... -
Page 19: Notes
All manuals and user guides at all-guides.com NOTES... - Page 20 All manuals and user guides at all-guides.com Copyright © 2010 A.O. Smith Corporation. All rights reserved.
- Page 21 All manuals and user guides at all-guides.com...
- Page 22 All manuals and user guides at all-guides.com...
- Page 23 All manuals and user guides at all-guides.com...
- Page 24 All manuals and user guides at all-guides.com...
- Page 25 All manuals and user guides at all-guides.com...
- Page 26 All manuals and user guides at all-guides.com...
- Page 27 All manuals and user guides at all-guides.com...
- Page 28 All manuals and user guides at all-guides.com...
- Page 29 All manuals and user guides at all-guides.com...
- Page 30 All manuals and user guides at all-guides.com...
- Page 31 All manuals and user guides at all-guides.com...
- Page 32 All manuals and user guides at all-guides.com...
- Page 33 All manuals and user guides at all-guides.com...
- Page 34 All manuals and user guides at all-guides.com...
- Page 35 All manuals and user guides at all-guides.com...
- Page 36 All manuals and user guides at all-guides.com...
- Page 37 All manuals and user guides at all-guides.com...
- Page 38 All manuals and user guides at all-guides.com...
- Page 39 All manuals and user guides at all-guides.com...
- Page 40 All manuals and user guides at all-guides.com...