Troubleshooting; Before Calling For Service - Pit Boss PB200P Instructions D'installation

WARNING
Spiders and insects can nest inside the burners of the grill and disrupt gas flow.
This very dangerous condition could cause a fire behind the valve panel, thereby
damaging the grill and making it unsafe for operation. Inspect the grill at least twice
a year.
When to Look for Spiders
You should inspect the burners at least twice a year or immediately after any of the
following conditions occur:
• The smell of gas in conjunction with burner flames appearing yellow.
• The grill does not reach temperature.
• The grill heats unevenly.
• The burners make popping noises.

BEFORE CALLING FOR SERVICE

If the grill does not function properly, use the following checklist before contacting
customer service.
Problems
Grill will not light.
Burner flame is yellow or
orange in conjunction with
gas odor.
Low heat with the control
knob on the "HI" setting.

TROUBLESHOOTING

What To Do
• Check to see if the liquid propane cylinder is empty.
• Check burner ports for any blockage. Use a soft wire
brush to clear plugged ports.
• Check the gas orifice on the burner for an obstruction. If
orifice is blocked, clean with a needle or thin wire. NEVER
USE A WOODEN TOOTHPICK.
• Check for spiders and insects.
• Call customer service at 888-804-7455
• Make sure the grill area is clear of dust.
• Make sure the burner and orifice are clean.
• Check for spiders and insects.
• Is there adequate gas supply available?
• Is the grill being preheated for 15 minutes?
19