Pool Heater Identification; Product Identification; Operation; Safety Rules - Pentair MiniMax Guide D'installation Et D'utilisation

POOL HEATER IDENTIFICATION

Pool heater models 525, 750 and 900, are designed for
indoor and outdoor installation. All these models are
operating with electronic ignition for natural gas or
propane fuel. Standard ratings for these heaters has
been set for elevation from sea level up to 2000 feet.
For elevation above 2000 feet, rating must be reduced
at the rate of 4% for each 1000 feet above sea level. It
is required to change the orifices on the main manifold
to reduced input in the heater for the specific installation
elevation. Please indicate the model number and the
altitude of the location where the unit will be installed
when you place an order for items required to convert
to a higher elevation.

Operation

SAFETY RULES

1. Spa or hot tub water temperatures should never
exceed 104° F (40° C). A temperature of 100° F
(38° C) is considered safe for a healthy adult. Special
caution is suggested for young children.
2. Drinking of alcoholic beverages before or during spa
or hot tub use can cause drowsiness which could lead
to unconsciousness and subsequently result in
drowning.
3. Pregnant women beware! Soaking in water above
102° F (39° C) can cause fetal damage during the first
three months of pregnancy (resulting in the birth of a
brain-damaged or deformed child). Pregnant women
should stick to the 100° F (38° C) maximum rule.
Should overheating occur or the gas supply fail to shut off, turn off the manual gas control valve to the appliance.
Do not use this heater if any part has been under water. Immediately call a qualified service technician to inspect
the heater and to replace any part of control system and gas control which has been under water.
P/N 470880

PRODUCT IDENTIFICATION

To identify the heater, see rating plate on the inner front panel of the
heater. There are two designators for each heater, one is the Model
Number and the other is the Heater Identification Number (HIN).
a. Model Number:
Example: 525
st rd
1 through 3 character indicated: Input rating (Btu/hr) X 1000
b. Heater Identification Number (HIN):
The following example simplifies the identification system.
1
H T R 5
1) HTR : Heater
2) (525, 750 & 900) : Input rating (Btu/hr) X 1000
3) SCD-1 : Commercial MiniMax w/CSD-1
4) Blank : Standard Model
5) N I : Gas type (Natural gas) & Intermediate Ignition Device
6) Options :
Blank: Standard Model
ASME: ASME Certified (Bronze Headers)
ASHI: ASME Certified Bronze Header & High Altitude Rating
HALT: High Altitude Rating
CAN: Canadian Compliance
CANH: Canadian Compliance and High Altitude
*
CSD-1 Controls apply only to the MiniMax Commercial Heater
4. Before entering the spa or hot tub, the user should
check the water temperature with an accurate
thermometer. Spa or hot tub thermostats may err in
regulating water temperatures by as much as 4° F
(2.2° C).
5. Persons with a medical history of heart disease,
circulatory problems, diabetes or blood pressure
problems should obtain their physician's advice before
using spas or hot tubs.
6. Persons taking medication which induce drowsiness,
such as tranquilizers, antihistamines or anticoagulants
should not use spas or hot tubs.
WARNING
2 3 4 5
2 5 C S D 1 - B a l n k N
*
Controls
4
6
I A S M E
Rev. K 5-31-06