Daily Inspection - TOHATSU MFS 15D Manuel De L'utilisateur

ENOM00322-1

1. Daily Inspection

Perform the following checks before and
after use.
Item
• Check the amount of fuel in the tank.
• Check for debris or water in the fuel filters.
Fuel System
• Check the rubber hoses for fuel leakage.
• Check for crack, leakage, damage in the fuel tank cap.
• Check for crack, damage in the gasket.
Fuel Tank Cap
• Check for leakage at full close.
• Check for ratchet performance.
Engine Oil • Check the oil level.
• Check that the main switch functions normally.
• Check that the battery electrolyte level and specific gravity are
normal.
• Check for loose connections on the battery terminal.
• Check that the stop switch functions normally and make sure
the stop switch lock is there.
Electrical
Equipment
• Check cords for loose connections and damage.
• Check the spark plugs for dirt, wear and carbon build-up.
• Check the warning LED lamp (ON for 5 to 7 secs.) when start
up.
• Check the rope for wear and chafing.
Recoil starter
• Check the ratchet engagement.
• Check that clutch engages correctly when operating the shift
Clutch and
lever.
Propeller Sys-
• Visually Check propeller for bent or damaged blades.
tem
• Check the propeller nut is tightened and the split pin is present.
• Check all the bolts attaching the motor to the boat.
Installation of
Motor
• Check the thrust rod installation.
Power Tilt • Check working of the tilt up and down of the motor.
• Check that cooling water is discharged from the cooling water
Cooling Water
check port after the engine has started.
• Check that there are tools and spare parts for replacing spark
Tools and
plugs, the propeller, etc.
Spares
• Check that you have the spare rope and stop switch lock.
INSPECTION AND MAINTENANCE
ENOW00078-0
Do not use outboard motor if any abnor-
mality is found during pre-operation check
or it could result in severe damage to the
motor or severe personal injury.
Points to Check
WARNING
Remedy
Replenish
Clean or replace if
necessary
Replace if necessary
Replace if necessary
Replace if necessary
Replace if necessary
Replace if necessary
Fill oil
Replace if necessary
Replenish or recharge
Retighten
Remedy or replace if
necessary
Correct or replace if
necessary
Clean or replace if
necessary
Repair
Replace if necessary
Replace if necessary
Adjust
Replace if necessary
Tighten or replace
Tighten
Replace if necessary
Repair
Repair
Order
Order
57
10