Cleaning Of The Flue; Cleaning Of The Glass; Cleaning Of The Ash Drawer; Majolicas - Dal Zotto CLASSICA 3,5 Instructions Pour L'installation, L'utilisation Et L'entretien

CLASSICA 350 – 450
13.1.

CLEANING OF THE FLUE

A correct lighting, the burning of a proper fuel, the loading of the
suggested quantity of fuel, the right adjustments of the secondary air
control, the sufficient draught of the chimney and the presence of air for
the combustion, are essential for the good operation of the appliance.
The appliance should be completely cleaned at least once a year or
every time it is needed (in case of bad working and low yield).
The cleaning must be carried out exclusively with cold equipment.
This operation should be carried out by a chimney sweeper who
can simultaneously perform an audit of the flue (checking of
possible deposits). During cleaning, remove from the cooker the
smokes exhaust small trunk and the smokes pipe.
The smokes collection casing can be cleaned either through the oven
(after removing the extractable plate of the oven Picture 8) the cooker
or from the top.
To this purpose remove the circles of the cooking plate and
disassemble the smokes pipe from the exhaust small trunk.
Cleaning can be made with a brush and a vacuum cleaner.
Pay attention that after cleaning all dismounted parts are
reinstalled hermetically.
13.2.

CLEANING OF THE GLASS

Thanks to a specific entry of the secondary air the building of deposit on the glass of the door is slowed down in a
remarkable way. However the building of this deposit cannot be avoided with the use of solid fuels such as wet wood,
and this is not to be considered as a defect of the appliance.
IMPORTANT: The cleaning of the sight glass must be carried out only and exclusively with cold appliance to
avoid the explosion of the same. Do not use cloths, abrasive or chemically aggressive products
by cleaning the hearth glass.
The correct lighting phase, the use of proper quantities and types of fuels, the correct position of the secondary air
regulator, enough draught of the chimney-flue and the presence of combustion air are the essential elements for the
optimal functioning of the appliance and for the cleaning of the glass.
BREAK OF GLASSES:
Considering that the glasses are manufactured in glass-ceramic and resistant to heat shock up to 750 °C,
they are not subject to thermal shocks. Their break can be caused only by mechanic shocks
(bumps or violent closure of the door, etc.). Therefore, their replacement is not included in the warranty.
13.3.

CLEANING OF THE ASH DRAWER

All the appliances are equipped with a shaking hearth grate and an ash drawer for the collection of the ashes.
It is suggested to empty periodically the ash drawer and to avoid it fills
completely in order not to overheat the grate. Moreover, we recommend
leaving always 3-4 cm of ash in the hearth.
ATTENTION: The ashes removed from the hearth have to be stored in a
container made of fire-resistant material equipped with an
air-tight cover. The container has to be placed on a fire-
resistant floor, far from flammable materials up to the
switching off and complete cooling.
IMPORTANT: If the grate will be taken off, please pay attention when it will
be placed again. The flat surface with the smaller holes for ashes should be
on the top, as if you place it on the contrary it would be more difficult to
remove the ashes from the grate. Picture 9
13.4.

MAJOLICAS

DAL ZOTTO has chosen majolica tiles, which are the result of high-quality artisan work and therefore the majolica
may present crackles, speckles, and shadings. These characteristics certify their precious origin.
Enamel and majolica, due to their different coefficient of dilatation, produce micro crackles, which show their authentic
feature.
1590001 – EN
Picture 9
Picture 8
23