Columbus AKS 80 Mode D'emploi page 25

Vacuum sweeper
AKS 80|BM 108
OBSERVE THE RULES AND PRECAUTIONS PROVIDED IN CHAPTER 9 "SAFETY STANDARDS"
1) In order for the batteries to last for a suitable amount of time, whether they are flat or tubular, never let them go
completely flat. COMPLETELY FLAT BATTERIES (INCLUDING NEW ONES) CANNOT BE RE-CHARGED.
2) Check the level of battery solution frequently, and add distilled water only, as needed.
3) Always re-charge the batteries without interrupting the cycle.
_____________________________________________________________________________________________________
THESE REPAIRS AND REPLACEMENTS ARE THOSE THAT HAVEN'T BEEN MENTIONED HERE. THEY MUST BE CARRIED OUT
BY PERSONNEL WITH TECHNICAL SKILLS TRAINED FOR THE PURPOSE. (SEE MANUAL COVER)
_____________________________________________________________________________________________________
   
Take the batteries out from their housing and store them in a dry and well-ventilated area. In order for unused batteries
to last for a suitable amount of time it is necessary to charge them and possibly top them up with distilled water every
30/40 days.
    Clean the dust filters and the hopper; if necessary, clean the hopper, observing the instructions provided in paragraph
"Debris hopper" in Chapter 13.
_____________________________________________________________________________________________________
DISMANTLING AND DEMOLITION ARE A CUSTOMER'S RESPONSABILITY. THESE OPERATIONS MUST BE PERFORMED IN
ACCORDANCE WITH APPLICABLE REGULATIONS, HANDING THE ENTIRE MACHINE OR ITS COMPONENTS TO COMPANIES
SPECIALISED IN SUCH SERVICES.
_____________________________________________________________________________________________________
IN ANY EMERGENCY SITUATION YOU MAY FIND YOURSELF IN, FOR EXAMPLE: IF YOU HAVE INADVERTENTLY DRIVEN THE
MACHINE OVER POWER CABLES SET UP ALONG THE FLOOR, WHICH HAVE TANGLED AROUND THE CENTRAL OR SIDE BROOM,
OR IF YOU CAN HEAR AN UNUSUAL NOISE FROM INSIDE THE MACHINE OR MOTOR, OR IF INCANDESCENT MATERIALS OR
FLAMMABLE LIQUIDS, CHEMICAL MATERIALS IN GENERAL, POISONS, ETC. HAVE BEEN COLLECTED.
YOU MUST:
Press the red button located to the left of the operator Detail 1 Fig. 12/A; as they are no longer powered, all of the motors will
immediately stop.
Two basic faults can effect AKS 70|BM 62: the machine raises dust during use, or leaves dirt on the floor; causes could be many but if the
machine is carefully operated and routine maintenance is properly carried out, such faults will not occur.
Specific maintenance operations for the batteries
CHAP. 14 – EXTRAORDINARY MAINTENANCE
CHAP. 15 – PUTTING OUT OF USE
CHAP. 16 – DISMANTLING
CHAP. 17 – EMERGENCY SITUATIONS
CHAP. 18 – TROUBLESHOOTING
25