Publicité
Les langues disponibles
Les langues disponibles
INSPECTION AND MAINTENANCE
NOTICE
MAINTENANCE,
REPAIR
OF
DEVICES AND SYSTEMS MAY BE PER-
FORMED BY ANY MARINE SI ENGINE
REPAIR ESTABLISHMENT OR INDIVIDUAL
USING ANY PART WHICH HAS BEEN
CERTIFIED UNDER THE PROVISIONS IN
THE CLEAN AIR ACT Sec. 207 (a) (2).
MAINTENANCE SCHEDULE
It is important to inspect and maintain your out-
board motor regularly. Follow the chart below.
Interval
Item to be serviced
Spark plug
Breather & Fuel line
Engine oil
Gear oil
Lubrication
Anodes (external)
* Anodes (internal
Powerhead)
Bonding wires
Battery
Low pressure fuel filter
* Low pressure fuel pump
filter
* Engine oil filter
* High pressure fuel filter
* Ignition timing
* Idle speed
* Valve clearance
* Water pump
* Water pump impeller
* Propeller nut & pin
* Bolts & Nuts
I: Inspect and clean, adjust, lubricate, or replace, if necessary T: Tighten R: Replace
NOTE:
Water-separating fuel filter
Replace the filter element every 12-months (or more frequently if recommended by the filter manufacturer).
REPLACEMENT
EMISSION
CONTROL
Initial 20 hrs.
or 1 month
–
I
R
R
I
I
–
–
I
I
R
–
I
–
–
–
I
T
At each interval, be sure to perform the indi-
cated service. Maintenance intervals should be
OR
judged by number of hours or number of
months, whichever comes first.
Exhaust gas contains carbon monoxide,
a dangerous gas that is difficult to detect
because it is colorless and odorless.
Breathing carbon monoxide can cause
death or severe injury.
Never start the engine or let it run indoors
or where there is little or no ventilation.
Every 100 hrs.
or 12 months
I
I
R
R
I
I
I
I
I
I
Replace every 400 hours or 2 years.
Replace every 1000 hours.
–
Replace every 1000 hours.
–
–
–
–
–
I
T
WARNING
Every 200 hrs.
Every 300 hrs.
or 12 months
or 36 months
–
–
–
–
–
–
–
–
–
–
R
I
I
–
I
I
–
–
–
–
–
–
–
–
–
–
–
–
–
–
–
I
–
R
–
–
37
Publicité
