Troubleshooting Guide - CRZ E-MD04 Manuel Utilisateur

charged until is has been repaired or replaced.
USE ONLY WITH THE RECOMMENDED CHARGER

TROUBLESHOOTING GUIDE

Problem
Vehicle does not run.
Vehicle was running but
suddenly stopped.
Short run time less than
15 minutes per charge
Possible cause
Undercharged battery.
Charger is not working.
Loose wires or connectors.
Burned-out fuse.
Motor or electrical switch
damage.
Undercharged battery
Battery is old and wil not
accept full charge.
Solution
Charge the battery. A new battery should have been
charged for at least 12 hours before using the vehicle
for the first time and up to 8 hours after each
subsequent use.
Check all connectors. Make sure the charger connector
is tightly plugged into the charging port, and that the
charger is plugged into the wall.
Make sure power flow to wall outlet is on.
You may check to see if your charger is working by
using a volt meter or asking the authorized service
center to test your charger for you.
Check all wires and connectors to make sure they are
tight.
The fuse will burn out and automatically shut off the
power if the motor is overloaded.
An excessive overload could cause the motor to
overheat. Refer to replacing the fuse instructions of this
manual. Correct the conditions that caused the fuse to
burn out and avoid repeatedly burning out fuse.
Contact the authorized service center for diagnosis and
repair.
Charge the battery. A new battery should have been
charged for at least 12 hours before using the vehicle
for the first time and up to 8 hours after each
subsequent use.
Check all wires and connectors. Make sure the battery
connector is tightly plugged into the charger connector,
and that the charger is plugged into the wall.
Make sure power flow to the wall outlet is on.
Even with proper care, a rechargeable battery does not
last forever. Average battery life is 1 to 2 years
depending on vehicle use and conditions. Replace only
with a replacement battery.