24 Flangia per il fissaggio alla caldaia 25 Disco di stabilità fiamma Vi sono due possibilità di blocco del bruciatore: Blocco apparecchiatura: l’accensione del pul- sante dell’apparecchiatura 12)(A) avverte che il RS 55 BLU 1190 bruciatore è in blocco. RS 65 BLU 1190 Per sbloccare premere il pulsante.
All manuals and user guides at all-guides.com BRENNERBESCHREIBUNG (A) BURNER DESCRIPTION (A) DESCRIPTION BRULEUR (A) 1 Flammkopf 1 Combustion head 1 Tête de combustion 2 Zündelektrode 2 Ignition electrode 2 Electrode d'allumage 3 Einstellschraube des Flammkopfes 3 Screw for combustion head adjustment 3 Vis pour réglage tête de combustion 4 Gasanschluß-Muffe 4 Sleeve...
La POTENZA MASSIMA va scelta entro l’ area A. La POTENZA MINIMA non deve essere infe- riore al limite minimo del diagramma: RS 55 BLU = 204 kW RS 65 BLU = 308 kW RS 85 BLU = 400 kW Attenzione: il CAMPO DI LAVORO è...
La PUISSANCE MINIMUM ne doit pas être infé- rieure à la limite minimum du diagramme. RS 55 BLU = 204 kW RS 55 BLU = 204 kW RS 65 BLU = 308 kW RS 65 BLU = 308 kW...
All manuals and user guides at all-guides.com PRESSIONE GAS Dp (mbar) RS 55 BLU Le tabelle a lato indicano le perdite di carico minime lungo la linea di alimentazione del gas in funzione della potenza del bruciatore in 2° stadio.
All manuals and user guides at all-guides.com GASDRUCK GAS PRESSURE PRESSION DU GAZ In den nebenstehenden Tabellen werden die The adjacent tables show minimum pressure Les tableaux ci-contre indiquent les pertes de Mindestströmungsverluste entlang der Gaszu- losses along the gas supply line depending on charge minimales sur la ligne d'alimentation en leitung in Abhängigkeit der Brennerleistung auf the burner output in 2nd stage operation.
Le lunghezze, L (mm), disponibili sono: Boccaglio 12): RS 55 BLU RS 65 BLU RS 85 BLU Per le caldaie con giro dei fumi anteriore 15), o con camera ad inversione di fiamma, eseguire una protezione in materiale refrattario 13), tra refrattario caldaia 14) e boccaglio 12).
2)(B) si ottengono ridu- zioni sulla formazione di NOx. Continuando l’esempio precedente, a pag. 12 si vede che per un bruciatore RS 55 BLU con potenza di 500 kW occorrono 4,3 mbar di pres- sione alla presa 6)(A). Se questa pressione non è...
Pour continuer l'exemple précédent, la page 12 gezeigt. indicates that for burner RS 55 BLU with output indique que pour un brûleur RS 55 BLU de puis- Falls es der Gasdruck erlaubt, werden durch of 500 kW a pressure of approximately 4,3 mbar sance 500 kW il faut 4,3 mbar environ de pres- das Schließen von Stellring 2)(B) Reduzie-...
P3 - Pressione a monte del filtro GAS TRAINS - RAMPE GAZ L BURNER - BRÛLEUR Ø C.T. Code RS 55 BLU RS 65 BLU RS 85 BLU Code Code L1 - Rampa gas fornita a parte con il codice indicato in tab. (C). 1” 1/4 3970144 •...
All manuals and user guides at all-guides.com GASZULEITUNG GAS LINE LIGNE ALIMENTATION GAZ • Gasarmaturen sind über Flansch 2), Dichtung • The gas train must be connected to the gas • La rampe du gaz doit être reliée au raccord du 3) und Schrauben 4), zur Brennerausstattung attachment 1)(A), using flange 2), gasket 3) gaz 1)(A), par la bride 2), le joint 3) et les vis 4)
All manuals and user guides at all-guides.com ELEKTROANLAGE ELECTRICAL SYSTEM INSTALLATION ELECTRIQUE ELECTRICAL SYSTEM as set up by the manu- ELEKTROANLAGE werkseitig ausgeführt INSTALLATION ELECTRIQUE effectué en facturer usine SCHEMA (A) LAYOUT (A) Brenner RS 55 - 65 - 85 BLU SCHEMA (A) Burners RS 55 - 65 - 85 BLU •...
TR con un ponte. TS - Telecomando di sicurezza: interviene in caso di TL guasto. VR - Valvola di regolazione VS - Valvola di sicurezza RS 55 BLU RS 65 BLU RS 85 BLU 230 V 400 V 230 V...
Page 23
All manuals and user guides at all-guides.com HYDRAULIKANSCHLÜSSE ELECTRICAL CONNECTIONS BRANCHEMENTS ELECTRIQUES Gemäß Norm EN 60 335-1 biegsame Kabel verwen- Use flexible cables according to EN 60 335-1 Utiliser des câbles flexibles selon la norme EN den: Regulations: 60 335-1: •...
Page 24
All manuals and user guides at all-guides.com SCHEMA (A) RS 55 - 65 - 85 BLU con controllo tenuta valvole gas RG1/CT RIELLO Allacciamento elettrico bruciatori RS 55-65- RS 55 - 65 - 85 BLU mit Dichtheitskontrolle der Gasventile RG1/CT RIELLO 85 BLU con controllo tenuta valvole gas RS 55 - 65 - 85 BLU with RG1/CT RIELLO leak detection control device RG1/CT RIELLO...
Page 25
All manuals and user guides at all-guides.com SCHEMA (A) LAYOUT (A) SCHEMA (A) Elektroanschluß der Brenner RS 55-65-85 Branchement électrique brûleurs RS 55-65- Electrical connection RS 55-65-85 BLU burn- BLU mit Dichtheitskontrolle der Gasventile 85 BLU avec dispositif de contrôle d'étan- ers with RG1/CT RIELLO leak detection con- RG1/CT RIELLO chéité...
All manuals and user guides at all-guides.com REGOLAZIONI PRIMA DELL'ACCENSIONE PRESSOSTATO GAS DI MIN. PRESSOSTATO ARIA La regolazione della testa di combustione, aria GAS-MINDESTDRUCKWÄCHTER LUFT-DRUCKWÄCHTER e gas, è già stata descritta a pag. 16. MIN GAS PRESSURE SWITCH AIR PRESSURE SWITCH Altre regolazioni da fare sono: Aprire le valvole manuali poste a monte della PRESSOSTAT GAZ MINIMUM...
All manuals and user guides at all-guides.com EINSTELLUNGEN VOR DER ZÜNDUNG ADJUSTMENTS BEFORE FIRST FIRING REGLAGES AVANT L'ALLUMAGE Le réglage de la tête de combustion, air et gaz, Die Einstellung des Flammkopfs, von Luft und Adjustment of the combustion head, and air and a déjà...
All manuals and user guides at all-guides.com REGOLAZIONE BRUCIATORE Per ottenere una regolazione ottimale del bru- ciatore è necessario effettuare l'analisi dei gas Bruciatore-Brenner-Burner-Brûleur Stadio-Stufe-Stage-Allure di scarico della combustione all'uscita della cal- daia. Regolare in successione: Spento/Aus/Off/Eteint 1 - Potenza all’accensione; 2 - Potenza bruciatore in 2°...
All manuals and user guides at all-guides.com BRENNEREINSTELLUNG BURNER CALIBRATION REGLAGE BRULEUR Für die optimale Einstellung des Brenners soll- The optimum calibration of the burner requires Pour obtenir un réglage optimal du brûleur, il ten die Abgase am Kesselausgang analysiert an analysis of the flue gases at the boiler outlet.
All manuals and user guides at all-guides.com Regolazione dell'aria Variare in progressione il profilo finale della camma 3)(A) agendo sulle viti 5). - Per aumentare la portata d’aria avvitare le viti. - Per diminuire la portata d’aria svitare le viti. 3 - POTENZA IN 1°...
All manuals and user guides at all-guides.com Lufteinstellung Adjusting air delivery Réglage air Über die Schrauben 5) das Endprofil des Nok- Progressively adjust the end profile of cam 3)(A) Modifier en progression le profil final de la came ken 3) (A) verändern. by turning the screws 5).
All manuals and user guides at all-guides.com 5 - PRESSOSTATO ARIA (A) Eseguire la regolazione del pressostato aria PRESSOSTATO ARIA 14)(A)p. 8 dopo aver effettuato tutte le altre regolazioni del LUFT-DRUCKWÄCHTER 14)(A)S. 8 bruciatore con il pressostato aria regolato a ini- AIR PRESSURE SWITCH 14)(A)p.
All manuals and user guides at all-guides.com 5 - LUFTDRUCKWÄCHTER (A) 5 - AIR PRESSURE SWITCH (A) 5 - PRESSOSTAT DE L'AIR (A) Die Einstellung des Luftdruckwächters erfolgt Effectuer le réglage du pressostat de l'air après Adjust the air pressure switch after having per- nach allen anderen Brennereinstellungen;...
All manuals and user guides at all-guides.com CONTROLLI FINALI (con bruciatore funzionante) VISORE FIAMMA - SICHTFENSTER FLAMME • Scollegare un filo del pressostato gas di FLAME INSPECTION WINDOW - VISEUR FLAMME minima: • Aprire il telecomando TL: • Aprire il telecomando TS: il bruciatore deve fermarsi •...
All manuals and user guides at all-guides.com ENDKONTROLLEN (bei Brenner in Betrieb) FINAL CHECKS (with burner running) CONTROLES FINAUX (brûleur en fonctionne- • Einen Draht des Gas-Mindestdruckwächters • Disconnect one of the wires on the minimum ment) • Débrancher un fil du pressostat de seuil mini- abtrennen: gas pressure switch: mum gaz:...
All manuals and user guides at all-guides.com STATUS • STATUS svolge tre funzioni: STATUS 1 - INDICA SUL VISORE V LE ORE DI FUN- ZIONAMENTO NUMERO ACCENSIONI DEL BRUCIATORE Ore di funzionamento totali Premere il pulsante "h1". Ore di funzionamento in 2° stadio Premere il pulsante "h2".
All manuals and user guides at all-guides.com STATUS STATUS STATUS • STATUS führt drei Funktionen aus: • The STATUS unit has three functions: • STATUS accomplit trois fonctions: 1 - ANZEIGE V MIT BETRIEBSSTUNDEN 1 - BURNER OPERATING HOURS AND THE 1 - INDIQUE SUR LE VISEUR V LES HEURES UND ANZAHL DER BRENNERZÜNDUN- NUMBER OF FIRINGS ARE SHOWN ON...
All manuals and user guides at all-guides.com COLORE (1) INCONVENIENTE CAUSA PROBABILE RIMEDIO CONSIGLIATO Il bruciatore non si avvia - Manca l'energia elettrica ......Chiudere interruttori - Controllare collegamenti - Un telecomando di limite o di sicurezza aperto .
All manuals and user guides at all-guides.com FARBE (1) STÖRUNGEN MÖGLICHE URSACHEN EMPFOHLENE ABHILFEN Brenner geht nicht an - Kein Strom........Schalter schließen - Anschlüsse kontrollieren - Eine Grenz- oder Sicherheitsfernsteuerung offen .
All manuals and user guides at all-guides.com COLOUR (1) FAULT PROBABLE CAUSE SUGGESTED REMEDY The burner does not start - No electrical power supply ......Close all switches - Check connections - A limiter or safety control device is open.
All manuals and user guides at all-guides.com COULEUR (1) INCONVENIENT CAUSE PROBABLE REMEDE CONSEILLE Le brûleur ne démarre pas - Absence de courant électrique ..... . Fermer interrupteurs - éontrôler fusibles - Une télécommande de limite ou de sécurité...
Page 44
All manuals and user guides at all-guides.com R.B.L. Riello Bruciatori Legnago s.p.a. Via degli Alpini 1 I - 37045 Legnago (VR) Tel.: +442 / 630111 Fax: +442 / 21980 Con riserva di modifiche - Änderungen vorbehalten! - Subject modifications - Sous réserve de modifications...