Serial/Model Number/Replacement Parts; Model Number Designations - Modine HDS Serie Manuel D'installation Et D'entretien

serIAl & model numBer / replACemenT pArTs
serial number designations
01 01 00 17 09 01 05 1000
motor vendor
Code
01 - Century
05 - Universal
etc.
fan vendor Code
01 - Revcor
08 - Brookside
etc.
unit series
Identifies the design series of
the unit
Control supplier
05 - Honeywell
17 - United Technologies
etc.
replacement parts
When requesting parts please contact your local representative. Please have full model and serial number available. If you require
assistance in locating your representative, please call the number located on the back page.
figure 1.1 Common replacement parts
model power limit Control
size exhauster switch
Hds 30 5H79402 5H75769B1
Hds 45
5H79402 5H75769B1
Hds 0 5H79402 5H75769B2
HdC 0
5H79402 5H75769B4
Hds 75 5H79402 5H75769B2
HdC 75 5H79402 5H75769B2
Hds 100
5H79795 5H75769B2
HdC 100 5H79795 5H75769B3
Hds 125
5H79795 5H75769B1
HdC 125 5H79795 5H75769B2
WHAT THIS WARRANTY COVERS
This warranty covers all defects in material and workmanship in your
Modine unit heater, when used for your home or garage.
WHAT THIS WARRANTY DOES NOT COVER
Unit heater, or any of its parts:
1. which have been improperly installed or removed.
2. which have been damaged other than by normal use.
3. which have not been properly maintained.
4. which have been exposed to gas input more than 5% higher than
specified on the serial plate of the unit heater, resulting in over-firing of
the heater.
5. which have been exposed to possibly corrosive chemicals or chemical
vapors (such as found in swimming pools), or potentially explosive or
flammable atmospheres laden with grain dust, sawdust, or similar air-
borne materials.
6. where any defect has been caused by abuse, misuse, neglect,
carelessness, or accident.
7. where the serial number of the unit heater has been altered, defaced,
or removed.
8. which are used in a confined space without adequate combustion air,
such as can be found in more air-tight construction.
WHO THIS WARRANTY COVERS
This warranty covers the purchaser of the unit heater or anyone else who
owns it during the warranty period.
HOW LONG THE WARRANTY LASTS
1. The warranty for the heat exchanger of the unit heater remains in force
for ten years from the date you purchased the unit heater.
2. The warranty on all other parts of the heater remains in force for two
years from the date you purchased the unit heater.
(Remove access cover to locate)
seQuenCe
numBer
Year of manufacture
05 - 2005
06 - 2006
etc.
Week of
manufacture
01 - 1st week of year
26 - 26th week of year
gas valve supplier
01 - Robertshaw
05 - Honeywell
etc.
(The list is subject to change. Please refer to unit mounted parts list for most up-to-date list.)
flame
Trans- pressure
roll-out
former switch
switch
5H75002-7 5H75029 5H79441-1
5H75002-7 5H75029 5H79441-2
5H75002-7 5H75029 5H79441-3
5H75002-7 5H75029 5H79441-3
5H75002-7 5H75029 5H79441-3
5H75002-7 5H75029 5H79441-3
5H75002-4 5H75029 5H79441-9
5H75002-4 5H75029 5H79441-9
5H75002-4 5H75029 5H79441-9
5H75002-4 5H75029 5H79441-9
modIne mAnufACTurIng CompAnY
lImITed WArrAnTY (residential use only)

model number designations

HDS 45
Hds - Tubular
Separated
Combustion
Propeller Unit
HdC - Tubular
Separated
Combustion
Blower Unit
mBH Input
30 - 30,000 Btu/hr input
45 - 45,000 Btu/hr input
etc...
Heat exchanger Type
A - Aluminized
s - Stainless Steel
Combination gas
Ignition
valve (1 stage)
Igniter Control
(1 stage)
Code 11
5H79636 5H79749 5H79751B
5H79636 5H79749 5H79751B
5H79636 5H79749 5H79751B
5H79636 5H79749 5H79751B
5H79636 5H79749 5H79751B
5H79636 5H79749 5H79751B
5H79636 5H79749 5H79751B
5H79636 5H79749 5H79751B
5H79636 5H79749 5H79751B
5H79636 5H79749 5H79751B
WHAT MODINE WILL DO TO CORRECT ANY WARRANTY DEFECTS,
AND HOW YOU CAN GET WARRANTY SERVICE
In the event of warranty failure, Modine will provide replacement parts
at Modine's cost. To obtain warranty repairs or replacement of defective
parts, you must, within the period of warranty coverage, contact the agency
from whom you purchased the unit heater. That seller, or the service
agency performing service for the seller, will determine whether or not
the unit heater, or any of its parts, is in fact defective, and will then either
repair or obtain and install the necessary replacement parts for you. If it
is determined that the unit heater or parts were not defective, you may be
charged for any replacement parts.
CAUTION - Do not attempt to repair the unit heater yourself, nor remove it
or any of its parts. This must be done by a qualified service agency.
If you have any questions about this warranty, call the person from
whom you purchased the unit heater; or a Modine Heating Products
Representative at 1-800-828-4328.
WHAT MODINE WILL NOT DO
Modine will not reimburse you for any labor costs or service charges
related to warranty repairs or replacements.
INCIDENTAL AND CONSEQUENTIAL DAMAGES DISCLAIMED
This warranty does not cover incidental damages, such as use of
substitute heating equipment, or other costs arising from the loss of use of
the unit heater. This warranty also does not cover consequential damages,
such as the cost of repairing or replacing other property which is damaged
when this unit heater does not work properly.
HOW STATE LAW RELATES TO THIS WARRANTY
Some states do not allow the exclusion or limitation of incidental or
consequential damages so the above limitations or exclusions may not
apply to you.
This warranty gives you specific legal rights, and you may also have other
rights which vary from state to state.
6-584.2
(Remove access cover to locate)
A S 01 1 1
gas valve Type
1 - Single Stage
2 - Two Stage
gas Type
1 - NG
2 - LP
power Code
01 - 115 volt, 60 hertz,
single phase
Ignition Type
s - Direct Spark
Combination gas
Ignition
valve (2 stage)
Control
(2 stage)
Code 21
Code 12
5H79869B NA NA
5H79869B NA NA
5H79869B NA NA
5H79869B NA NA
5H79869B 5H79804B 5H79748B 5H79871B
5H79869B 5H79804B 5H79748B 5H79871B
5H79869B 5H79804B 5H79748B 5H79871B
5H79869B 5H79804B 5H79748B 5H79871B
5H79869B 5H79804B 5H79748B 5H79871B
5H79869B 5H79804B 5H79748B 5H79871B
Code 22
NA
NA
NA
NA
1