SOLIS VAC PREMIUM 574 Mode D'emploi page 56

WHY DO V AC U U M P A C K E D F OO DS
s
LA ST LO NGE R?
1. Chemical reactions in food with air, ambient temperature and dampness,
enzym-reactions, the formation of micro-organisms or contamination by insects
can spoil food.
2. The main reason why food nutrients lose their irmness and lavour is the oxygen
in the air. The formation of micro-organisms is usually caused by air, because
this removes the moisture of the foods, on the other hand, it also transports
ambient moisture back into the food if they are not hermetically sealed. Frozen
foods get in the freezer air, often the freezer burn.
3. The vacuum-system removes up to 90% of air from the packaging. Since air is
approximately 21% oxygen, it means that only 2–3% of the oxygen remains in
the packaging. However in an oxygen content of less than 5%, most micro-or-
ganisms cannot multiply.
4. In general, micro-organisms can be divided into three categories: mould, yeasts
and bacteria, they are present everywhere, but can only cause damage in
certain conditions.
5. In an environment with little air or moisture, mould cannot develop. In mois-
ture, sugar and warmth, yeast can spread with or without air, cooling slows the
growth of yeast and freezing stops it altogether.
6. Bacteria can spread with or without air.
One of the most dangerous bacteriums is Clostridium botulinum which can,
under certain conditions, spread without air – it only needs a temperature of
between 4 °C and 46 °C. It spreads in food without acid, in environments with
little acid and in temperatures that are above 4 °C for long periods of time.
7. Frozen, dried or acid rich foods or foods with a high salt or sugar content, cannot
contain the bacterium Botulinum.
The following foods can be lightly infected with Botulinum:
– Foods without acid e.g. meat, seafood, poultry, ish, eggs, mushrooms and
olives in brine
– Foods with little acid like most vegetable
– Foods with moderate acid content such as tomatoes, onions, chilli-peppers,
igs and cucumbers.
8. To store the above at-risk foods, you should keep them in the refrigerator for
short term storage or in the freezer, for long term storage, and after heating
they need to be eaten straight away.
9. Some enzymes in foods can change the colour, texture and lavour of foods,
which depends on storage time, storage temperature and oxygen. To prevent
this enzyme reaction, vegetable should be blanched or steam cooked for a short
time, or cooked in the microwave. Foods with a high acid content such as most
fruits, must not be blanched. In this case, vacuum packing is enough to slow or
inhibit the enzyme reaction.
110
10. Some dry foods, such as lour and cereals, contain insect larvae. If the food
isn't vacuum packed, these can hatch during storage, making the food inedible.
To prevent this these foods should be vacuumed.
11. Generally, foods should be stored at low temperatures since most micro-organ-
isms can also spread without air.
12. If the temperature in your fridge is above 4°C then this can, most of all during
long-term storage, support the growth of dangerous micro-organisms. Therefore
the temperature setting in your fridge should be max. 4°C or less.
13. If the temperature in your freezer is −17 °C or less, it is ideal for storing food, but
remember: freezing does not kill micro-organisms, it only slows their growth.
14. The shelf life of vacuum packed dried foods is also longer, the cooler the storage
temperature is: For every 10 °C cooler the storage temperature, the shelf life
extends by 3 – 4 times.
F U R T H ER TI P S FOR S UC C E SS F UL V AC U UM I NG:
1. Always wash your hands before preparing and vacuuming, equally the materials
and appliance which you use, should be absolutely clean.
2. As soon as the foods have been vacuumed, put them in the fridge or freezer,
do not leave them to sit at room temperature. Make sure that the temperature
in the refrigerator does not increase.
3. Vacuum packing extends the shelf life of dried foods, foods with high fat con-
tent quickly become rancid in warm temperatures and oxygen. Vacuum packing
extends the shelf life of nuts, coconuts or cereals. Store these in a cool, dark
place.
4. Vacuum packing does not extend the shelf life of fruit and vegetables such as
apples, bananas, potatoes and root vegetables, unless they are peeled irst!
5. Cabbage vegetables such as broccoli, caulilower or cabbage give off gas when
vacuum packed fresh for refrigeration. To preserve them, they must be irst
blanched, then frozen before packing.
111