Engine Oil Filter; Fuel Filter; Flushing The Water Passages - Suzuki DF100 Manuel Du Propriétaire

NOTICE
If you add diluted sulphuric acid to the
battery after it has been initially serviced,
you will damage the battery.
NEVER add diluted sulphuric acid to the
battery after it has been initially serviced.
Follow the battery
instructions for specific maintenance
procedures.

ENGINE OIL FILTER

The engine oil filter must be changed by autho-
rized Suzuki Marine
Replace engine oil filter with a new one at initial
20 hours (1 month).
Replace engine oil filter with a new one at every
200 hours (12 months).

FUEL FILTER

The fuel filter must be inspected by authorized
Suzuki Marine Dealer periodically.
Low pressure fuel filter
Inspect low pressure fuel filter at every 50 hours
(3 months).
Replace low pressure fuel filter with a new one
at every 400 hours (2 years).
High pressure fuel filter
Replace high pressure fuel filter with a new one
at every 1000 hours.
48
manufacturer's
Dealer periodically.
FLUSHING THE WATER
PASSAGES
After operation in muddy, brackish, or salt
water, you should flush the water passages and
motor surface with clean, fresh water.
If you do not flush the water passages, salt can
corrode the motor and shorten its life. Flush the
water passages as follows.
ENGINE RUNNING – Vertical position –
Suzuki recommends that you flush the water
passage by using this method.
To flush the water passages, you must obtain a
commercially available engine flush device.
 WARNING
Exhaust gas contains carbon monoxide,
a dangerous gas that is difficult to detect
because it is colorless and odorless.
Breathing carbon monoxide can cause
death or severe injury.
Never start the engine or let it run indoors
or where there is little or no ventilation.
 WARNING
Failure to take proper precautions when
flushing the water passages can be haz-
ardous.
When flushing the water passages,
always take the following precautions:
• Make sure that the engine remains in
NEUTRAL. If shifted into gear, the pro-
peller shaft will turn and could cause
severe personal injury.
• Make sure the motor is properly
clamped to a secure stand or boat, and
remain in attendance until flushing is
completed.
• Keep children and pets away from the
area, and stay clear of all moving parts.