CAME BXL Serie Manuel D'installation, D'utilisation Et D'entretien page 28

GENERAL PRECAUTIONS FOR INSTALLERS
Follow all of these instructions. Improper installation can cause serious bodily
Before continuing, also read the general precautions for users.
T
HIS PRODUCT MUST ONLY BE USED FOR ITS SPECIFICALLY INTENDED PURPOSE
C S.P.A.
AME IS NOT LIABLE FOR ANY DAMAGE CAUSED BY IMPROPER
'
MANUAL S PRODUCT IS DEFINED BY MACHINERY DIRECTIVE
Q -
UASI COMPLETED MACHINERY IS
, ,
BUT WHICH ALONE CANNOT ENSURE A CLEARLY DEFINED APPLICATION
DESTINED TO BE INCORPORATED OR ASSEMBLED TO OTHER MACHINERY OR OTHER PARTLY
OR APPARATUSES TO BUILD MACHINERY THAT IS REGULATED BY
MUST BE COMPLIANT WITH
G
IVEN THESE CONSIDERATIONS
,
EXPERT QUALIFIED STAFF
WHICH WOULD RESULT IN WARRANTY LOSS
MANUALS OF ALL THE OTHER DEVICES USED FOR YOUR AUTOMATION SYSTEM
RANGE SHOWN ON THE OPERATOR IS SUITABLE TO THE LOCATIONS WHERE IT WILL BE INSTALLED
,
CABLES INSTALLATION AND TESTING MUST FOLLOW STATE
• I -
F THE POWER SUPPLY CABLE IS DAMAGED
AN AUTHORIZED TECHNICAL ASSISTANCE CENTER
D
URING ALL PHASES OF THE INSTALLATION MAKE SURE YOU HAVE CUT OFF THE MAINS POWER SOURCE
OPERATOR CANNOT BE USED WITH GATES FITTED WITH PEDESTRIAN DOORS
TED ONLY WHEN THE PEDESTRIAN DOOR IS IN SAFETY POSITION
'
BETWEEN THE GATE S MOVING AND FIXED PARTS DUE TO THE GATE
,
TOR CHECK THAT THE GATE IS IN PROPER MECHANICAL CONDITION
:
PROPERLY CLOSES IF ANY OF THESE CONDITIONS ARE NOT MET
. • M
REQUIREMENTS AKE SURE THE GATE IS STABLE AND THE CASTORS FUNCTION PROPERLY AND ARE WELL
,
SED AND THAT IT OPENS AND CLOSES SMOOTHLY
ENTIRELY ABOVE THE SURFACE AND FREE OF ANY IMPEDIMENTS TO THE GATE
UPPER GUIDE MUST NOT CAUSE ANY FRICTION
M
AKE SURE THE OPERATOR IS INSTALLED ONTO A STURDY SURFACE THAT IS PROTECTED FROM ANY COLLISIONS
M
AKE SURE THAT MECHANICAL STOPS ARE ALREADY INSTALLED
FROM THE GROUND OR FROM ANY OTHER ACCESS LEVEL
. • D
SITUATIONS O NOT FIT THE OPERATOR UPSIDE DOWN OR ONTO ELEMENTS THAT COULD YIELD TO ITS WEIGHT
,
NECESSARY ADD REINFORCEMENTS TO THE FASTENING POINTS
• C
SURFACES HECK THAT NO LAWN WATERING DEVICES SPRAY THE OPERATOR WITH WATER FROM THE BOTTOM UP
• A
NY RESIDUAL RISKS MUST BE INDICATED CLEARLY WITH PROPER SIGNAGE AFFIXED IN VISIBLE AREAS
WHICH MUST BE EXPLAINED TO END USERS
SITE TO PREVENT UNAUTHORIZED PERSONS FROM ENTERING THE AREA
,
CAUTIONARY SIGNS SUCH AS THE DOOR PLATE
PROPER PROTECTIONS TO PREVENT MECHANICAL HAZARDS WHEN PEOPLE ARE LOITERING AROUND THE MACHINERY
,
RANGE OF ACTION FOR EXAMPLE TO PREVENT FINGER CRUSHING BETWEEN THE RACK AND PINION
CABLES MUST RUN THROUGH THE CABLE GLANDS AND MUST NOT TOUCH ANY HEATED PARTS
,
TRANSFORMER AND SO ON
POWER SUPPLY THAT IS COMPLIANT WITH THE INSTALLATION RULES
SUPPLY ACCORDING TO CATEGORY
1.85
LEAST M FROM THE PERIMETER OF THE GATE
. • A
OUTSIDE THE GATE LL SWITCHES IN MAINTAINED ACTION MODE MUST BE POSITIONED SO THAT THE MOVING GATES
,
LEAVES THE TRANSIT AREAS AND VEHICLE THRU
ALSO AWAY FROM ANY MOVING PARTS
, , 1.5
FITTED AT AT LEAST
COLLISION FORCE TEST USE A SUITABLE SENSITIVE SAFETY
B
EFORE HANDING OVER TO USERS
M D . M
ACHINERY IRECTIVE
,
PROTECTION DEVICES AND ALSO THE MANUAL RELEASE
⚠
WARNING! Important safety instructions.
P -
ARTLY COMPLETED MACHINERY IS A SET THAT ALMOST CONSTITUTES A MACHINE
E 2006/42/CE
UROPEAN DIRECTIVE
,
ALL PROCEDURES STATED IN THIS MANUAL MUST BE EXCLUSIVELY PERFORMED BY
. • T
HE MANUFACTURER DECLINES ANY LIABILITY FOR USING NON
• K
EEP THIS MANUAL INSIDE THE TECHNICAL FOLDER ALONG WITH THE
,
IT MUST BE IMMEDIATELY REPLACED BY THE MANUFACTURER OR BY
,
. • M
. • S
,
). • M
AKE SURE YOU HAVE SET UP A SUITABLE DUAL POLE CUT OFF DEVICE ALONG THE
III
SURCHARGE CONDITIONS
-
• U
NLESS THE ACTION IS KEY OPERATED
M FROM THE GROUND AND MUST NOT BE ACCESSIBLE TO THE PUBLIC
,
CHECK THAT THE SYSTEM IS COMPLIANT WITH THE
AKE SURE THE SETTINGS ON THE OPERATOR ARE ALL SUITABLE AND THAT ANY SAFETY AND
harm.
,
WRONGFUL AND UNREASONABLE USE
2006/42/CE
. P
D
IRECTIVE
AND CURRENT
- - -
OF THE ART PROCEDURES AS DICTATED BY REGULATIONS
,
OR IN ANY CASE BY QUALIFIED STAFF
. • M
AKE SURE THAT PEOPLE ARE NOT ENTRAPPED
'
S MOVEMENT
,
THAT IT IS PROPERLY BALANCED AND THAT IT
,
DO NOT CONTINUE BEFORE HAVING MET ALL SAFETY
. • T
HE GUIDE RAIL MUST BE WELL
AKE SURE THAT OPENING AND CLOSING LIMITERS ARE FITTED
• I
F THE OPERATOR IS INSTALLED LOWER THAN
,
FIT ANY PROTECTIONS AND SIGNS TO PREVENT HAZARDOUS
• D
O NOT INSTALL DOOR OR GATE LEAVES ON TILTED
UITABLY SECTION OFF AND DEMARCATE THE ENTIRE INSTALLATION
,
ESPECIALLY MINORS AND CHILDREN
,
THE GATE PLATE WHEREVER NEEDED AND IN PLAIN SIGHT
. I
T SHOULD COMPLETELY CUT OFF THE POWER
. • A
LL OPENING CONTROLS MUST BE INSTALLED AT
' ,
S WORKING AREA OR WHERE THEY CANNOT BE REACHED FROM
WAYS ARE COMPLETELY VISIBLE
- . I
EDGE NSTALL IT PROPERLY AND ADJUST AS NEEDED
,
WORK PROPERLY
. A
NY OTHER USE IS DANGEROUS
" -
AS PARTLY COMPLETED MACHINERY
-
ARTLY COMPLETED MACHINERY IS ONLY
-
COMPLETED MACHINERY
2006/42/CE. T
HE FINAL INSTALLATION
E
UROPEAN REFERENCE STANDARDS
-
ORIGINAL PRODUCTS
. • C
HECK THAT THE TEMPERATURE
,
TO PREVENT ANY RISK
,
UNLESS ITS OPERATION CAN BE ACTIVA
. B
EFORE INSTALLING THE OPERA
-
FASTENED TO THE GROUND
' . • T
S MOVEMENT
) • T
,
SUCH AS THE MOTOR
,
AND YET THE SWITCHES MUST BE
,
THE CONTROL DEVICES MUST BE
2006/42/CE
. • A
FFIX A PERMANENT TAG
.
. • T
HIS
".
,
.
;
. • L
AYING THE
•
. • T
HE
-
-
- -
GREA
,
HE RAILS OF THE
•
•
2.5
. I
F
.
. A
LL OF
. • A
FFIX
. • U
SE
'
S
HE ELECTRICAL
,
. • T
O PASS THE
. •
UNIFORMED
,