Best Practices; Troubleshooting For Under Cooked Eggs; Troubleshooting Eggs Leaking Out Of Egg Rings - Antunes ESDZ-1200 Manuel Du Propriétaire

Troubleshooting for Under Cooked Eggs

1. Level unit - adjust feet if necessary, as shown on
page 5. The unit must be level before use. Before
using the unit, adjust the legs of the unit as need-
ed and use a level. If a level is not available, pour
a small amount of water directly onto the center
of the cool grill surface. The water should pool in
the middle and not drain toward a certain section
of the unit. Make adjustments as required. Turn
legs clockwise to shorten or counter-clockwise to
lengthen. See image below (Side view of unit).
2. Do not use cold water in trough. Use room tem-
perature water. Warm water is preferred.
3. Ensure trough is filled to the tup and not over/
under-filled.
4. Ensure Start button is pressed promptly after lid is
closed and trough is filled.
5. Yolks must be broken with spatula.
6. Clean the grill surface after each cooking cycle.
7. Use the correct amount of butter/oil on grill sur-
face.
8. Confirm ready light is solid green prior to starting
another cooking cycle.
9. Check grill temperature according to the section
titled Checking Grill Platen Temperature in the
Maintenance section of this manual.
10. Regularly check the holes in the trough to ensure
there are no clogs.
P/N 1013028 Rev. B 10/20

BEST PRACTICES

Troubleshooting Eggs leaking out of Egg
Rings
Egg Ring Replacement depends on usage but in gen-
eral, Egg Rings should be replaced yearly. If eggs begin
to leak out of the Egg Rings:
1. Inspect the Egg Rings for damage regularly. Clean
the unit and flip the Egg Rings 180° degrees or
replace the Egg Rings if required.
2. Egg Rings should be installed in the Egg Rack so
they can move up and down to ensure they are
flush against the grill surface. If the Egg Rings
do not move freely up and down within the Rack,
remove the Egg Ring and reshape it to its nor-
mal form, and reinstall. Replace the Egg Ring if
required.
3. The Egg Rings should sit flush against the grill
surface and hold the egg inside the Egg Ring
while cooking. Review the section titled Best
Practices/Troubleshooting for Under Cooked
Eggs in this manual. Inspect the Egg Rings for
damage. Flip or replace as required.
9
EGG STATION DUAL ZONE
®