Metabo HPT NT 65MA4 Manuel D'instructions Et De Sécurité page 11

BEFORE OPERATION
Read section titled "SAFETY" (pages 4 – 8).
Make sure of the followings before operation.
WORKING ENVIRONMENT
WARNING
No fl ammable gas, liquid or other
fl ammable objects at worksite.
Clear the area of children or
unauthorized personnel.
AIR SUPPLY
NEVER use reactive
gases or other bottled
gases. Explosion may
occur.
WARNING
Never connect Nailer to pressure
which potentially exceeds 200 psi
(13.7 bar 14 kgf/cm
fails.
Never use non relieving coupler on
Nailer.
1. Power source
Use only clean, dry, regulated compressed
air as a power source for this Nailer.
Air compressors
compressed air to this Nailer must comply
with the requirements of the latest version
of ANSI Standard B 19.3 "Safety Standard
For Compressors For Process Industries."
Moisture or oil in the air compressor may
accelerate wear and corrosion in the
Nailer.
Drain daily.
2. Filter-Regulator-Lubricator
Use a regulator with a pressure range of 0
– 120 psi (0 – 8.3 bar 0 – 8.5 kgf/cm
Filter-regulator-lubricator
an optimum condition for the Nailer and
extend the Nailer life. These units should
always be used.
000Book̲NT65MA4(S)̲US̲metabo.indb 11 000Book̲NT65MA4(S)̲US̲metabo.indb 11
DANGER
) if a regulator
2
used to supply
).
2
units supply
Filter:
The fi lter removes
dirt mixed in
Drain daily unless fi tted with an automatic
drain.
Keep the fi lter
maintenance.
Regulator:
The regulator controls the operating
pressure for safe operation of the Nailer.
Inspect the regulator before operation to
be sure it operates properly.
Lubricator:
The lubricator supplies an oil mist to the
Nailer.
Inspect the lubricator before operation to
be sure the supply of lubricant is adequate.
Use metabo HPT pneumatic tool lubricant.
Nailer Side
Lubricator
3. Air hose
Compressed air supply hoses shall have
a minimum working pressure rating equal
to or greater than the pressure from the
power source if a regulator fails, or 150
psi (10.4 bar 10.6 kgf/cm
greater.
4. Air consumption
Using the Air consumption table and the
Air compressor size formula, fi nd a correct
compressor size.
Air consumption table
psi
Operating
(bar)
pressure
(kgf/cm ) (5.6)
2
ft /cycle
3
Air
consumption
(ltr/cycle) (1.07) (1.18) (1.29)
English
moisture and
compressed air.
clean by regular
Regulator
Compressor
Side
Filter
), whichever is
2
80 90 100
(5.5) (6.2) (6.9)
(6.3) (7)
.038 .042 .045
11
2018/02/07 14:38:35 2018/02/07 14:38:35