Cleaning Instructions; Care And Cleaning - Manitowoc Cleveland SGL-30-T1 Manuel De L'opérateur

CLEANING INSTRUCTIONS

CAUTION
SURFACES MAY BE
EXTREMELY HOT!

CARE AND CLEANING

Cooking equipment must be cleaned
regularly to maintain its fast, efficient
cooking performance and to ensure its
continued safe, reliable operation. The
best time to clean is shortly after each
use (allow unit to cool to a safe
temperature).
WARNINGS
Do not use
detergents or
cleansers that are
chloride based or
contain quaternary
salt.
Chloride Cleaners
Do not use a metal
bristle brush or
scraper.
Wire Brush &
Scrapers
Steel wool should
never be used for
cleaning the stainless
steel.
Steel Pads
Unit should never be
cleaned with a high
pressure spray hose.
High Pressure
Spray Hose
Do not leave water
sitting in unit when
not in use.
Stagnant
Water
CLEANING INSTRUCTIONS
1. Turn unit off.
2. Remove drain screen (if applicable). Thoroughly wash and rinse the screen
either in a sink or a dishwasher.
3. Prepare a warm water and mild detergent solution in the unit.
4. Remove food soil using a nylon brush.
5. Loosen food which is stuck by allowing it to soak at a low temperature
setting.
6. Drain unit.
7. Rinse interior thoroughly.
8. If the unit is equipped with a T T a a n n g g e e n n t t D D r r a a w w - - O O f f f f V V a a l l v v e e , clean as follows:
a) Disassemble the draw-off valve first by turning the valve knob counter-
clockwise, then turning the large hex nut counter-clockwise until the
valve stem is free of the valve body.
b) In a sink, wash and rinse the inside of the valve body using a nylon
brush.
c) Use a nylon brush to clean tangent draw-off tube.
d) Rinse with fresh water.
e) Reassemble the draw-off valve by reversing the procedure for
disassembly. The valve's hex nut should be hand tight only.
9. Using mild soapy water and a damp sponge, wash the exterior, rinse, and
dry.
NOTES
³ For more difficult cleaning applications one of the following can be used:
alcohol, baking soda, vinegar, or a solution of ammonia in water.
³ Leave the cover off when the kettle is not in use.
³ For more detailed instructions refer to Stainless Steel Equipment Care and
Cleaning (www.nafem.org/resources/stainlesssteelfinal.doc) on Nafem's
website (www.nafem.org).