General Information; Information On Environemental Protection; Compressed-Air Connection - Orgapack OR-V 40 P Mode D'emploi

ORGAPACK OR-V 40 P
2
These operating instructions are intended to simplify
familiarisation with the strapping tool and the possibili-
ties of application for the intended purpose. The operat-
ing instructions contain important information concern-
ing the safe, proper and efficient use of the strapping
tool. Observation of the information will help to avoid
danger, reduce repairs and stoppages and increase the
reliability and service life of the strapping tool.
The operating instructions must always be available at
the place of operation of the strapping tool. They must
be read and observed by all persons concerned with
work on the strapping tool. This work specifically in-
cludes operation, refilling of operating material, fault
elimination and maintenance.
In addition to the operating instructions and the regula-
tions for accident prevention effective in the country of
use and place of application, the recognised technical
regulations for safety and proper working must also be
observed.
2.1 INFORMATION ON ENVIRONMENTAL
PROTECTION
This tool is manufactured without any physical or
chemical substances which could be dangerous to
health.
For disposal of all the parts, the governmental
instructions must be observed.
10

GENERAL INFORMATION

2.2 COMPRESSED-AIR CONNECTION

The sealing piston is lubricated by oil mist of the
compressed air. Properly prepared compressed air is
therefore essential for trouble-free operation of the tool.
This can only be ensured by a reliably functioning
maintenance unit, consisting of water separator,
pressure reducing valve with pressure gauge and oil
mist lubricator.
The oil mist lubricator should supply sufficient oil. The
length of the hose between the OR-V 40 P and the
maintenance unit should not exceed 5 m (15 ft). The
internal diameter of the pipe should be at least
10 mm ( 3
form loops, where oil can collect.
CAUTION!
Used where there is
danger to life and health.
WARNING!
Used for danger which
can cause material
damage.
NOTE!
Used for general infor-
mation and information
which if not followed can
cause faults in the
operating sequence.
/ "). It must be ensured that the hose does not
8
08.00/WE