Authorized Service - LGB 28002 Instructions De Service

Consider this when setting up
your layout. Ernst Paul Lehmann
Patentwerk and LGB of America
are not liable for any damages.
SERVICE
Do-It-Yourself Service Levels
Level - Beginner
Level - Intermediate
Level - Advanced
Attention! Improper service will
void your warranty. For quality
service, contact your authorized
retailer or an LGB factory service
station (see Authorized Service).
Lubrication
The side rod ends should be lubri-
cated occasionally with a small
amount of LGB Maintenance Oil
(50019).
Cleaning
This model can be cleaned exter-
nally using a mild detergent and
gentle stream of water. Do not
immerse this model.
Attention! This model is equip-
ped with sound electronics. Do
not expose the speaker directly to
water.
Replacing the light bulbs
Front lower lanterns: Pull the
lantern housing away from the
model. Remove and replace the
bulb. Reassemble.
Front upper and rear lower lan-
terns: Remove the ring around
the lantern lens. Carefully pry the
lens away from the lantern. Using
tweezers, remove and replace the
bulb. Reassemble.
Rear upper lantern: Carefully
pull the wires down to remove the
light socket from the lantern.
Replace the bulb. Reassemble.
Cab light: Using tweezers, remo-
ve and replace the bulb.
Replacing the
smoke generator
- Pull the safety cover out of the
smoke stack (Fig. 3).
- Pull the smokebox front out of
the boiler (Fig. 4).
- Unplug the wires for the old
smoke generator from the circuit
board inside the boiler.
10
- Push the old generator out of
the smokestack.
- Push the replacement generator
into the stack and plug the wires
into the loco circuit board.
- Reassemble.
Replacing the traction tire
- Remove the hex screw on the
wheel with the traction tire and
remove the side rod.
- Use a small, straight-blade scr-
ewdriver to pry the old traction
tire out of the wheel groove.
- Use a small, straight-blade scr-
ewdriver to gently pry the new
traction tire into the wheel groo-
ve.
- Make sure that the traction tire is
seated properly in the wheel
groove.
Maintenance parts
50010 Smoke
Fluid
50019 Maintenance Oil
51020 Gear Lubricant
55020 MTS Decoder
62210 28001-Series Motor
63120 Brushes, Assembled,
14 mm and 16 mm,
8 pieces
65853 Smoke Generator, 5V
68511 Plug-In Bulb, Clear, 5 V,
10 pieces
69104 Traction Tire, 37.5 mm,
10 pieces

AUTHORIZED SERVICE

Improper service will void your
warranty. For quality service,
contact your authorized retailer or
one of the following LGB factory
service stations:
Ernst Paul Lehmann Patentwerk
Reparatur-Abteilung
Saganer Strasse 1-5
D-90475 Nürnberg
GERMANY
Telephone: (0911) 83707 0
Fax: (0911) 83707 70
LGB of America
Repair Department
6444 Nancy Ridge Drive
San Diego, CA 92121
USA
Telephone: (858) 535-9387
Fax: (858) 535-1091
and Cleaning