Publicité
EN
low profile errp
CONDENSATE REMOVAL PUMP
Designed exclusively to fit underneath retail refrigeration cabinets the
lightweight plastic ERRP (Economical Retail Refrigeration Pump) allows for the
removal of defrost and contaminated water.
Description: The pump is designed to be installed
underneath 'island' refrigeration units to collect
water during the defrost cycle, where direct
drainage is not available. The pump is triggered
by a hall-effect float/sensor arrangement and will
discharge the water to a maximum height of 21
metres to a suitable drain.
There is a high level safety switch which will either
enable the plant to be switched off or sound an
alarm in the event of a pump failure.
Installation Notes: IMPORTANT: Only one
refrigeration unit must drain into this pump. This
pump is designed to sit level on its base. Ensure that
there are no kinks or trapped parts in the discharge
piping, which must have an internal diameter of
9mm and be secured to the pump outlet with a
clamp. The float must always be located around the
float column, with the magnet uppermost.
IMPORTANT: For hygiene and performance, we
strongly recommend an anti-bacterial "Stayclean"
strip is ALWAYS positioned between the two filters in
the tank. The anti-bacterial strip must be BETWEEN
the two filters and NOT in the float chamber.
Service Guide: Flush the pump through with
anti-bacterial wash and clean both filters every 6
months or more often if required, to avoid sludge
build up.
Replacement anti-bacterial "Stayclean" strips are
available from Aspen Pumps.
N.B. The contractors should satisfy themselves that
any chemicals used are compatible with the pump.
LOW PROFILE ERRP SPECIFICATIONS
Max. flow
Max. rec. head
Tank capacity
Sound level@1m
Power supply
Rated
Class
Max. unit output
Max. water temp
Inlet/outlet
IP Protection
Safety switch
Thermal protection
Fully potted
Self priming
190L/h @ 0 head
21m
3.5L
60dB(A)
230V AC 50-60Hz 0.2A
Continuous
I appliance
n/a
40°C / 104°F
50mm in, 10mm out
IPX4
3.0A Normally closed
✓
n/a
n/a
40
30
20
10
230V
0
50
ELECTRICAL CONNECTION
Brown
Blue
Green / yellow
Black
Black
IMPORTANT: THE SAFETY SWITCH SHOULD ALWAYS BE UTILISED.
Float
Pump
PCB
Motor
Pump Casing
21m max. recommended head
100
150
200
LITRES PER HOUR
Live
Neutral
Earth
N/C
Common
Safety
On
Off
Float
Fine filter
Stay Clean Strip
Large filter
250
300
Live
Neutral
Earth
N/C
Common
Publicité
