General Information; Operator Safety - Briggs & Stratton 520000 Vanguard Diesel Manuel De L'opérateur

General Information

This manual contains safety information to make you aware of the hazards and risks
associated with engines and how to avoid them. It also contains instructions for the
proper use and care of the engine. Because Briggs & Stratton Corporation does not
necessarily know what equipment this engine will power, it is important that you read and
understand these instructions and the instructions for the equipment. Save these
original instructions for future reference.
For replacement parts or technical assistance, record below the engine model, type, and
code numbers along with the date of purchase. These numbers are located on your
engine (see the Features and Controls page).
Date of purchase:
Engine model:
Model:
Engine Power Rating Information
For 3/LC engines, gross power ratings are based on SAE J1995 criteria and net power
ratings are based on SAE J1349 criteria. Actual power output of production engines
installed in applications may vary depending on a number of factors, including the engine
RPM limit of the application, environmental conditions, engine/equipment maintenance,
and other variables.

Operator Safety

SAFETY AND CONTROL SYMBOLS
Fire Moving Parts
Fast
Stop
On Off Fuel Shutoff
Read Manual Hot Surface
The safety alert symbol is used to identify safety information about hazards that can
result in personal injury. A signal word (DANGER, WARNING, or CAUTION) is used with the
alert symbol to indicate the likelihood and the potential severity of injury. In addition, a hazard
symbol may be used to represent the type of hazard.
DANGER
indicates a hazard which, if not avoided, will result in death or
serious injury.
WARNING
indicates a hazard which, if not avoided, could result in death or
serious injury.
CAUTION
indicates a hazard which, if not avoided, could result in minor or
moderate injury.
NOTICE
indicates a situation that could result in damage to the product.
4
MM/DD/YYYY
Type:
Toxic Fumes
Oil
Explosion Shock
Wear Eye
Kickback Protection
Frostbite Hot Liquid or Steam
WARNING
Certain components in this product and its related accessories contain
chemicals known to the State of California to cause cancer, birth defects, or
other reproductive harm. Wash hands after handling.
WARNING
The engine exhaust from this product contains chemicals known to the
State of California to cause cancer, birth defects, or other reproductive
harm.
Code:
WARNING
Briggs & Stratton does not approve or authorize the use of these engines
on 3-wheel All Terrain Vehicles (ATVs), motor bikes, fun/recreational
go-karts, aircraft products, or vehicles intended for use in competitive
events. Use of these engines in such applications could result in property
damage, serious injury (including paralysis), or even death.
NOTICE: This engine was shipped from Briggs & Stratton without oil. Before you start
the engine, make sure you add oil according to the instructions in this manual. If you
start the engine without oil, it will be damaged beyond repair and will not be covered
under warranty.
WARNING
Fuel and its vapors are extremely flammable and explosive.
Fire or explosion can cause severe burns or death.
When Adding Fuel
Slow
Turn engine off and let engine cool at least 2 minutes before removing the fuel

cap.
Fill fuel tank outdoors or in well-ventilated area.

Do not overfill fuel tank. To allow for expansion of the fuel, do not fill above the

bottom of the fuel tank neck.
Fuel
Keep fuel away from sparks, open flames, pilot lights, heat, and other ignition

sources.
Check fuel lines, tank, cap, and fittings frequently for cracks or leaks.

Replace if necessary
If fuel spills, wait until it evaporates before starting engine.

Hazardous
When Starting Engine
Chemical
Ensure that muffler, fuel cap, and air cleaner are in place and secured.

When Operating Equipment
Do not tip engine or equipment at angle which causes fuel to spill.

Never start or run the engine with the air cleaner assembly (if equipped) or the

air filter (if equipped) removed.
When Transporting Equipment
Transport with fuel tank EMPTY or with fuel shut-off valve OFF.

When Storing Fuel Or Equipment With Fuel In Tank
Store away from furnaces, stoves, water heaters or other appliances that have

pilot lights or other ignition sources because they can ignite fuel vapors.
WARNING
Starting engine creates sparking.
Sparking can ignite nearby flammable gases.
Explosion and fire could result.
If there is natural or LP gas leakage in area, do not start engine.

Do not use pressurized starting fluids because vapors are flammable.

VanguardEngines.com