Table Des Matières - Pentair MASTERTEMP 175K BTU/HR Guide D'installation Et D'utilisation

Contents
Section 1. Heater Identification Information .......................................................................
Section 2. Warning and Safety Information .........................................................................
Important Notices .................................................................................................................................................................................
Warranty Information ............................................................................................................................................................................
Code Requirements ..............................................................................................................................................................................
Consumer Information and Safety Information ......................................................................................................................................
General Specifications .........................................................................................................................................................................
Section 3. Installation .............................................................................................................
Heater Description ................................................................................................................................................................................
Putting the Heater into Service ............................................................................................................................................................
Specifications ......................................................................................................................................................................................
Plumbing Connections ..........................................................................................................................................................................
Valves ..................................................................................................................................................................................................
Manual By-Pass ..................................................................................................................................................................................
Water Connections ...............................................................................................................................................................................
Below Pool Level Installation ................................................................................................................................................................
Gas Connections .................................................................................................................................................................................
Sediment Traps ....................................................................................................................................................................................
Gas Pipe Sizing ...................................................................................................................................................................................
Testing Gas Pressure / Gas Pressure Requirements ..........................................................................................................................
Outdoor Installation / Heater Clearances ............................................................................................................................................
Outdoor Installation Venting Guidelines .............................................................................................................................................
Indoor Venting - General Requirements (Category I and Category III requirements) ......................................................................
Heater Clearances - General Requirements (Indoor Installation US / Canada) ..............................................................................
Outside Vent Cover Removal ..............................................................................................................................................................
Combustion Air Supply / Direct Air Intake Duct with 3-inch PVC Pipe (Indoor Installation) ..................................................................
Corrosive Vapors and Possible Causes ..............................................................................................................................................
Vent Installation (Indoor Installation for US and Canada) ....................................................................................................................
Vertical Venting - Negative Pressure .................................................................................................................................................. 21 - 23
Horizontal or Vertical Venting - Positive Pressure ..............................................................................................................................
Connecting Special Gas Venting ........................................................................................................................................................ 24 - 26
Garage or Utility Room Installation .....................................................................................................................................................
Control Panel Indexing .......................................................................................................................................................................
Final Installation Check .......................................................................................................................................................................
Electrical Connections ........................................................................................................................................................................
Fireman's Switch Connection / Remote Control Connections ............................................................................................................
MasterTemp Heater Wiring Diagram ...................................................................................................................................................
Electrical Schematic Ladder Diagram .................................................................................................................................................
Section 4. Operation ...............................................................................................................
Basic System Operation ......................................................................................................................................................................
HSI (Hot-Surface Ignition) Lighting / Operation ...................................................................................................................................
Operating ............................................................................................................................................................................................
To Turn Off Gas to Appliance ..............................................................................................................................................................
Safety Controls ....................................................................................................................................................................................
Section 5. Troubleshooting ....................................................................................................
Initial Troubleshooting and Troubleshooting Chart .................................................................................................................................
Heater Will Not Fire Troubleshooting ....................................................................................................................................................
LED Diagnostics ..................................................................................................................................................................................
Burner / Heat Exchanger Troubleshooting ............................................................................................................................................
Section 6. Maintenance ..........................................................................................................
Care and Maintenance ..........................................................................................................................................................................
Pressure Relief Valve ...........................................................................................................................................................................
After Start-Up ......................................................................................................................................................................................
Spring, Fall and Winter Operation .........................................................................................................................................................
Maintaining Pool Temperature ...............................................................................................................................................................
Energy Saving Tips ..............................................................................................................................................................................
Chemical Balance ................................................................................................................................................................................
Replacement Parts ..............................................................................................................................................................................
Addendum: For Gas Pipe Escutcheon Installation ..............................................................
Rev. N 10/2018 MASTERTEMP Pool and Spa Heater Installation and User's Guide
3
4
5
5
5
6
6 - 9
9
10
10
10
11
12
12
12
13
13
14
14
15
15-16
16
17
18
18
18
19-20
20
21
24
27
28
28
29
30
31
32
33
33
33
34
34
35 - 37
38
38
39 - 42
43 - 44
45
46
46
46
47
47
48
49
48 - 49
50 - 54
55