Table des Matières
Publicité
ANNUAL MAINTENANCE
Major maintenance items that may be requested in
addition
Fork
Shock
Clean and grease steering head bearings and seals
Replace fiberglass in the muffler
Treat electric contacts and switches with an aerosol
protector
Replace the clutch hydraulic fluid
Replace the brake fluid
Checks and major maintenance to be performed by
the rider
Check the engine oil level
Check brake fluid level
Check status of the brake pads
Check function of electric components (headlight/tail/stop
turn signals, horn, computer lightning, commands etc)
Lubricate the throttle cable
Regularly purge the air from the fork legs
Regularly clean the fork dust seals
Clean and lubricate chain, check tension and adjust if necessary
Clean air filter and box
Check tires and tire pressure
Check the coolant level
Check the sealing of the circuit of fuel, water and brakes
Check status of all the controls
Check the brakes
Spray anti-corrosion protector on all non -painted parts
(except for the brake parts and the exhaust system)
Spray protector on electrical switches
Check rims and spoke tension
Check tightness of nuts, screws and clamps
Maintenance schedule
MAINTENANCE SCHEDULE
At least once a year
Competition use
Recreational use
Clutch lever tension
Level of oil in the clutch master cylinder
Length of the clutch springs
Clutch disc wear
Wear on the clutch nuts and clutch bell
Cylinder
Before
After
Complet Piston
each use
each use
Piston bearing
Conrod + bearings
Crankshaft bearings
Gearbox
Gearbox oil
Reed valve petals
Sparkplug
Link rear suspension
Bearings of wheels and steering
Carburetor
Sealing and attachment of the exhaust
Status and position of the electric wires
Status of the foot brake pedal and hand brake lever
Sealing and running of fork/shock
Chain, sprockets, guides, chain tension
Caption : C : Change | N : Clean | V : Check (cleanness, settings, lubrication)
ATTENTION :
Check the tightening of the screws of your bike after the first ride / the first hours of use.
In competition you have to perform the 20 hour maintenance schedule after each race!
This should not be exceeded by more than 2 hours.
The services performed by the Sherco dealer do not replace routine service and maintenance by the rider!
Sherco ST Series
Every
Every
End of
20h
40h
Every
running-
20h
Every
Every
in (5h)
40h
80h
V
V
V
V
V
V
V
V
V
V
V
V
V
V
C
C
V
C
C
C
C
V
C
N
C
V
V
V
V
V
V
N
N
N
V
V
V
V
V
V
V
V
V
V
V
V
V
V
V
V
V
V
V
V
Every
60h
Every
120h
V
V
V
V
V
V
C
V
C
C
V
C
V
V
V
N
V
V
V
V
V
24
Publicité
Table des Matières
