LGB 27211 Instructions De Service page 8

this setting, even if the model is used on
an analog layout.
Attention! After extended operation, this
model may leave carbon dust or other
debris around the track. This dust and
debris can stain carpet and other mate-
rials. Consider this when setting up your
layout. LGB are not liable for any damages.
SERVICE
Do-It-Yourself Service Levels
Level - Beginner
Level - Intermediate
Level - Advanced
Attention! Improper service will void
your warranty. For quality service, con-
tact your authorized retailer or an LGB
factory service station (see Authorized
Service).
Lubrication
The axle bearings and the side rod ends
should be lubricated occasionally with a
small amount of LGB Maintenance Oil
(50019).
Cleaning
This model can be cleaned externally
using a mild detergent and gentle
stream of water. Do not immerse this
model.
Replacing the light bulbs
Front/rear lanterns: Carefully pry the
lens away from the lantern. Using
tweezers, remove and replace the bulb.
Reassemble.
Cab light: Using tweezers, remove and
replace the bulb.
Replacing the
smoke generator
- Pull the safety cover out of the smoke
stack (Fig. 4).
- Use pliers or tweezers to pull the old
smoke generator out of the stack (Fig. 5).
8
- Cut the wires to the old generator and
attach them to the replacement gener-
ator (Fig. 6).
- Insulate the connections and push the
replacement generator into the stack.
- Reassemble.
Replacing the traction tire
- Remove the two hex head screws that
attach the side rods to the rear wheels.
- Remove the side rods from the rear
wheels.
- Use a small, straight-blade screwdriv-
er to replace the traction tire:
- Pry the old traction tire out of the
wheel groove.
- Gently insert the new traction tire into
the wheel groove.
- Make sure that the traction tire is seat-
ed properly in the wheel groove.
Maintenance parts
50010 Smoke and Cleaning Fluid
50019 Maintenance Oil
51020 Gear Lubricant
55020 MTS Decoder
62201 Standard Motor with Short
Shaft
63120 Brushes, Assembled, 14 mm
and 16 mm,
8 pieces (3 sets required)
63218 Standard Pick-Up Shoes,
2 pieces
65853 Smoke Generator, 5 V
68511 Plug-In Bulb, clear,
5 V, 10 pieces
69104 Traction Tire, 37.5 mm, 10
pieces