Publicité
3
EN lock bracket
ES brida de cerradura
FR support de verrouillage
EN
ASSEMBLING TOP TO BOTTOM
5. While someone holds the top, align the slot in the front hinge (attached to Carrier bottom) with the corresponding hole
in the Carrier top. Attach the front hinge as illustrated in figure 3 above. Place the large screw (J) through large cap
retainer (N), then through hole in Carrier top and through hinge slot. Place large washer (L) over the screw thread (J) and
thread on the large nut (H). Tighten nut loosely for now. [DO NOT SNAP LARGE CAP (M) ON AT THIS TIME.]
Repeat procedure for rear hinge.
6. Attach the lid supports at the front and rear of the Carrier bottom to the Carrier top as illustrated in figure 3 above. Place small screw
(K) through small cap retainer (P), then through hole in Carrier top and through lid support attachment plate. Thread on small nut (I).
Tighten nut loosely for now. [DO NOT SNAP SMALL CAP (O) ON AT THIS TIME.] Repeat for second hole and again for remaining two
holes at opposite end of box. Tighten all small screws – [DO NOT OVER TIGHTEN.] Snap on small caps (O) at all four locations.
7. Check for correct alignment of lock assembly by closing and locking the carrier. If the lock does not align with the lock bracket and does
not lock properly, adjust the position of the Carrier top with hinge, until they lock. Tighten large screws and snap on large caps.
8. To close Carrier, make sure the locks are in the open (horizontal) position with the key removed and pull Carrier top downward from both ends.
9. To lock Carrier, insert key, pull down on flange of carrier top and turn key to the locked position (vertical). FOR SAFETY, BOTH CAMLOCKS (D)
MUST PROPERLY ENGAGE THE BOTTOM LOCK BRACKETS.
EN NOTE: The lock needs to be in the "locked" position for assembly to the Carrier top and for assembly
of the lock locator. Remove key to prevent movement of lock hook.
506-7414
H
L
N
J
EN hinges
ES bisagras
FR charnières
EN OPEN
ES ABIERTO
FR OUVERT
M
I
EN LOCKED
ES CERRADO
FR VERROUILLÉ
P
K
O
3 of 6
Publicité
